Abstract
Microalloying additions of Si are known to increase significantly the response to age hardening of 2xxx series Al-Cu-Mg alloys, and commercial alloys such as 2618 are based on this effect. Previous work has attributed this effect to a refined dispersion of S′ or S phase (Al2CuMg) precipitates. This work reports the results of a detailed microstructural characterization, employing transmission electron microscopy-based techniques, on the effects of Si additions to a base Al-2.5Cu-1.5Mg (wt pct) alloy. It was found that the peak hardness microstructure contains a fine and uniform dispersion of Si-modified Guinier-Preston-Bagaratsky (GPB) zones. These zones are lath shaped, possessing {100} α facets, elongated along 〈100〉 α directions and contain Si. The S phase was also observed at peak hardness, although it is concluded that these precipitates do not contribute significantly to hardening due to their coarse dispersion, which arises from their heterogeneous nucleation on the quenched-in defect structure. Overaging was associated with the replacement of the zones by the S phase through a process involving dissolution and reprecipitation together with heterogeneous nucleation of S at the zones. The precipitation of ϑ′ (Al2Cu) and σ(Al5Cu6Mg2) phase was also observed in alloys containing ≥0.5 wt pct Si. It is demonstrated that the total solute content of the alloy has a major influence on the precipitation reactions during aging.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
G.B. Brook: “Precipitation in Metals,” Special Report No. 3, Fulmer Research Institute, Stoke Poges, United Kingdom, 1963.
J.T. Vietz and I.J. Polmear: J. Inst. Met., 1966, vol. 94, pp. 410–19.
S.P. Ringer, T. Sakurai, and I.J. Polmear: Acta Mater., 1997, vol. 45, pp. 3731–44.
S.P. Ringer, S.K. Caraher, and I.J. Polmear: Scripta Mater., 1998, vol. 39, pp. 1559–67.
P. Ratchev, B. Verlinden, P. De Smet, and P. Van Houtte: Acta Mater., 1998, vol. 46, pp. 3523–33.
L. Reich, S.P. Ringer, and K. Hono: Phil. Mag. Lett A, 1999, vol. 79, pp. 639–48.
R.N. Wilson and P.G. Partridge: Acta Metall., 1965, vol. 13, pp. 1321–27.
Y.A. Bagaryatsky: Dokl. Akad. SSSR, 1952, vol. 87, p. 397.
Y.A. Bagaryatsky: Dokl. Akad. SSSR, 1952, vol. 87, p. 559.
J.M. Silcock: J. Inst. Met., 1960, vol. 89, pp. 203–10.
F. Cuisiat, P. Duval, and R. Graf: Scripta Metall., 1984, vol. 18, pp. 1051–56.
A.M. Zahra, C.Y. Zahra, C. Alfonso, and A. Charai: Scripta Mater., 1998, vol. 39, pp. 1555–58.
A.M. Zahra, C.Y. Zahra, W. Lacom, and K. Spirdek: Proc. Int. Conf. on Light Metals, Amsterdam, June 20–22, 1990, ASM International, Materials Park, OH, T. Khan and G. Effenberg, eds., 1990, pp. 633–39.
A.K. Jena, A.K. Gupta, and M.C. Chaturvedi: Acta Metall., 1989, vol. 37, pp. 885–95.
H. Perlitz and A. Westgren: Ark. Kemi. Miner. Geol., 1943, vol. 13, p. B16.
A.K. Gupta, P. Gaunt, and M.C. Chaturvedi: Phil. Mag. A, 1987, vol. 55, pp. 375–87.
C.B. Zhang, W. Sun, and H.Q. Ye: Phil. Mag. Lett. A, 1989, vol. 59, pp 265–71.
S.P. Ringer, K. Hono, I.J. Polmear, and T. Sakurai: Appl. Surf. Sci., 1996, vols. 94–95, pp. 253–60.
R.N. Wilson, D.M. Moore, and P.J.E. Forsyth: J. Inst. Met., 1967, vol. 95, pp. 177–83.
R.N. Wilson: J. Inst. Met., 1969, vol. 97, pp. 80–86.
G.C. Weatherly and R.B. Nicholson: “Ministry of Aviation,” Department of Materials, Progress Report Number PD/25/025, 1964.
G.C. Weatherly and R.B. Nicholson: “Ministry of Aviation,” Department of Materials, Progress Report Number PD/29/025, 1965.
H. Suzuki, I. Araki, M. Kanno, and K. Itoi: Trans. Jpn. Inst. Light Met., 1977, vol. 27, p. 239.
A.K. Gupta, A.K. Jena, and M.C. Chaturvedi: Mater. Sci. Technol., 1987, vol. 3, pp. 1012–17.
A.K. Gupta, M.C. Chaturvedi, and A.K. Jena: Mater. Sci. Technol., 1989, vol. 5, pp. 52–55.
A.K. Jena, A.K. Gupta, and M.C. Chaturvedi: Metall. Trans. A, 1993, vol. 24A, pp 2181–87.
M.C. Chaturvedi, A.K. Gupta, and A.K. Jena: Mater. Sci. Eng., 1989, vol. A110, pp. 187–92.
T. Gladman and J.H. Woodhead: J. Iron Steel Inst., 1960, Feb., pp. 189–93.
R.D. Schueller, A.K. Sachdev, and F.E. Wawner: Sripta Metall., 1992, vol. 27, pp. 617–22.
D.L.W. Collins: J. Inst. Met., 1958, vol. 86, pp. 325–36.
J. Takamura, M. Koiwa, and J. Furukawa: J. Nucl. Mater., 1978, vols. 69–70, p. 738
S.P. Ringer and K. Hono: Mater. Characterization, 2000, vol. 44, pp. 101–32.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Hutchinson, C.R., Ringer, S.P. Precipitation processes in Al-Cu-Mg alloys microalloyed with Si. Metall Mater Trans A 31, 2721–2733 (2000). https://doi.org/10.1007/BF02830331
Received:
Issue Date:
DOI: https://doi.org/10.1007/BF02830331