Abstract
Carbon-coated nickel silicide nanowires (C-coated NiSi NWs) were grown in a home-made chemical vapor deposition (CVD) reactor. The coating of semiconductor or metal nanowires with nano-sized carbon layer is effective to prevent the oxidation of the nanowires, resulting in the stabilization of electrical properties of nanodevices. The growth of the NiSi nanowires and the coating of the NWs with carbon layers simultaneously took place in the reaction. The current-voltage curve of individual NiSi nanowire showed highly linear behavior, indicating the good ohmic contact without the insulating layer. The resistivity of the NiSi nanowire was about 370 ΜΩ-cm at room temperature, decreased monotonically as the temperature was lowered, and became saturated at low temperatures, indicating the growth of metallic NiSi nanowires. Field emission measurements showed that the C-coated NiSi nanowires were an excellent field emitter with large emission current densities at very low electric field.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Bockrath, M., Cobden, D. H., McEuen, P. L., Chopra, N. G., Zettl, A., Thess, A. and Smalley, R. E., “Single-Electron Transport in Ropes of Carbon Nanotubes,”Science,275, 1922 (1997).
Carim, A. H., Lew, K. K. and Redwing, J. M., “Bicrystalline Silicon Nanowires”,Adv. Mater.,13, 1489 (2001).
Chen, C.C., Yeh, C. C., Chen, C H., Yu, M. Y., Liu, H. L., Wu, J. J., Chen, K. H., Chen, L. C., Peng, J. Y. and Chen, Y. F., “Catalytic Growth and Characterization of Gallium Nitride Nanowires,”J. Am. Chem. Soc.,123, 2791 (2001).
Chen, C. C., Yeh, C. C., Liang, C H., Lee, C. C., Chen, C H., Yu, M. Y., Liu, H. L., Chen, L. C., Lin, Y S., Ma, K J. and Chen, K. H., “Preparation and Characterization of Carbon Nanotubes Encapsulated GaN Nanowires,”J. Phys. & Chem. of Solids,62, 1577 (2001).
Chen, Y. Q., Zhang, K., Miao, B., Wang, B. and Hou, J. G., “Temperature Dependence of Morphology and Diameter of Silicon Nanowires Synthesized by Laser Ablation”,Chem. Phys. Lett.,358, 396 (2002).
Derycke, V., Martel, R., Appenzeller, J. and Avouris, P., “Carbon Nanotube Inter- and Intramolecular Logic Gates,”Nano Lett.,1, 453 (2001).
Duan, X. F., Huang, Y., Cui, Y., Wang, J. F. and Lieber, C M., “Indium Phosphide Nanowires as Building Blocks for Nanoscale Electronic and Optoelectronic Devices”,Nature,409, 66 (2001).
Gudiksen, M. S., Lauhon, L. J., Wang, J. F., Smith, D. C. and Lieber, C. M., “Growth of Nanowire Superlattice Structures for Nanoscale Photonics and Electronics”,Nature,415, 617 (2002).
Hensel, J. C., Tung, R. T., Poate, J. M. and Unterwald, F. C., “Electrical Transport Properties of CoSi2 and NiSi2 Thin Films”,Appl. Phys. Lett.,44, 913 (1984).
Kim, T.Y., Lee, S. H., Mo, Y. H., Shim, H.W., Nahm, K. S., Suh, E.-K., Yang, J. W., Lim, K. Y. and Park, G. S., “Growth of GaN Nanowires on Si Substrate using Ni Catalyst in Vertical Chemical Vapor Deposition Reactor,”J. Cryst. Growth,257, 97 (2003).
Lee, S. T., Wang, N. and Lee, C. S., “Semiconductor Nanowires: Synthesis, Structure and Properties,”Mater. Sci. Eng. A,286, 16 (2000).
Martel, R., Schmidt, T., Shea, H. R., Hertel, T. and Avouris, P., “Single- and Multi-wall Carbon Nanotube Field-effect Transistors,”Appl. Phys. Lett.,73, 2447 (1998).
Nahm, K. S., Kim, K. C., Park, C. I., Lim, K. Y., Yang, Y. S. and Seo, Y. H., “Growth Chemistry and Interface Characterization of Single Crystal SiC on Modified Si Surface”,J. Chem. Eng. Japan,34, 692 (2001).
Osawa, A. and Okamoto, M., “Influence of the Si Substrate on Nickel Silicide Formed from Thin Ni Films,”Sci. Rep. Tohuku Univ. Ser.,127, 134 (1939).
Pradhan, B. K., Kyotani, T. and Tomita, A., “Nickel Nanowires of 4 nm Diameter in the Cavity of Carbon Nanotubes,”Chem. Commun.,14, 1317(1999).
Rinzler, A. G., Hafner, J. H., Nikolaev, P., Lou, L., Kim, S. G., Tomanek, D., Colbert, D. and Smalley, R. E., “Unraveling Nanotubes: Field Emission From an Atomic Wires”,Science,269, 1550 (1995).
Shang, N.G., Meng, F.Y., Au, F. C. K., Li, Q., Lee, C. S., Bello, I. and Lee, S. T., “Fabrication and Field Emission of High-Density Silicon Cone Arrays”,Adv. Mater.,14, 1308 (2002).
Wong, K. W., Zhou, X. T., Au, F. C. K., Lai, H. L., Lee, C. S. and Lee, S. T., “Field-emission Characteristics of SiC Nanowires Prepared by Chemical-vapor Deposition,”Appl. Phys. Lett.,75, 2918 (1999).
Yi, W K., Jeong, T.W., Yu, S. G., Heo, J. N., Lee, C S., Lee, J. H., Kim, W S., Yoo, J. B. and Kim, J. M., “Field-Emission Characteristics from Wide-Bandgap Material-Coated Carbon Nanotubes”,Adv. Mater.,14, 1464 (2002).
Yi, W K., Jeong, T.W., Yu, S. G., Heo, J. N., Lee, C S., Lee, J. H., Kim, W.S., Yoo, J.-B. and Kim, J.M., “Field-Emission Characteristics from Wide-Bandgap Material-Coated Carbon Nanotubes,”Adv. Mater.,14, 1464 (2002).
Zhang, X. W., Wong, S. P., Cheung, W. Y. and Zhang, F., “Electrical Transport Properties of NiSi2 Layers Synthesized by Metal Vapor Vacuum-arc Ion Implantation: Temperature Dependence and Two-band Model,”Appl. Phys. Lett.,80, 249 (2002).
Zhang, Y.F., Tang, Y. H., Zhang, Y., Lee, C. S., Bello, I. and Lee, S. T., “Deposition of Carbon Nanotubes on Si Nanowires by Chemical Vapor Deposition”,Chem. Phys. Lett.,330, 48 (2000).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Lee, K.S., Lee, S.H., Mo, Y.H. et al. Electrical characterization of C-coated nickel silicide nanowires grown on Ni-loaded Si substrate. Korean J. Chem. Eng. 21, 1240–1244 (2004). https://doi.org/10.1007/BF02719501
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02719501