Abstract
Silicalite and highly silicious ZSM-5 were synthesized using two reaction mixtures with different crystal growth environments, a dispersed low density mixture and a separated high density mixture, at 93 ±3 ‡C under the atmospheric pressure. Nucleation behavior and the transformation process of two mixtures were investigated utilizing various analytical techniques such as XRD, FT-IR, TGA, SEM, and pH measurement. During the induction period, the same intermediate phase was observed in both mixtures. The presence of this phase was found to be dependent on the degree of dilution of the reaction mixture. After the induction period, a sharp increase in both the degree of crystallization and the pH of the reaction mixture was detected. This indicates that the pH change in the reaction mixture is closely related to the crystallization process. From these observations, a crystallization mechanism is proposed on the basis of the appearance of stable silicate species and the role of OH- ions during the induction period. According to this mechanism, MFI-type zeolite grows by condensation reaction among the stable silicate species formed during the induction period.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Beelen, T. P. M., Dokter, W. H., van Garderen, H. F. and van Santan, R. A., in Occelli, Mario L., and Kessler, H. (Eds.), “Synthsis of Porous Materials: Zeolites, Clays, and Nanostructures”, Marcel Dekker,Inc, New York, 59 (1997).
Burggraaf, A. J., Vroon, Z. A. E. P., Keizer, K. and Verweij, H., “Permeation of Single Gases in Thin Zeolite MFI Membranes”,J. Membr. Sci.,144, 77 (1998).
Burkett, S. L. and Davis, M. E., “Mechanism of Structure Direction in the Synthesis of Si-ZSM-5 — An Investigation by Intermolecular1H-Si-29 CP MAS NMR”,Phys. Chem.,98, 4647 (1994).
Casci, J. L. and Lowe, B. M., “Use of pH-Measurements to Monitor Zeolite Crystallization”,Zeolites,3, 186 (1983).
Chung, K.-H., Kim, K.-S. and Seo, Gon, “The Rate of Nuclei Formation of ZSM-5 Zeolite”,Korean J. Chem. Eng.,9, 144 (1992).
Connor, C. T. O., Van Steen, E. and Dry, M. E., “New Catalytic Applications of Zeolites for Petrochemicals”, in Chon, H., Woo, S. I. and Park, S.-E. (Eds.), “Recent Advances and New Horizons in Zeolite Science and Technology;Stud. Surf. Sci. Catal.,102, 323 (1996).
Corkery, R. W. and Ninham, B. M., “Low-Temperature Synthesis and Characterization of a Stable Colloidal TPA-Silicalite-l Suspension”,Zeolites,18, 379 (1997).
Coudurier, G., Naccache, C. and Verdrine, J. C., “Uses of I.R. Spctroscopy in Identifying ZSM Zeolite Structure”,J. Chem. Soc. Chem. Comm., 1413 (1982).
Cundy, C. S., Lowe, B. M. and Sinclair, D. M., “Direct Measurements of the Crystal-Growth Rate and Nucleation Behavior of Silicalite, a Zeolitic Silica Polymorph”,J. Cryst. Growth.,100, 189 (1990).
Cundy, C. S., Hentry, M. S. and Plaisted, R. J., “Zeolite Synthesis Using a Semicontinuous Reactor, Part 1: Controlled Nucleation and Growth of ZSM-5 Crystals having Well-defined Morphologies”,Zeolites,15, 379 (1995).
Derouane, E. G., Detremmerie, S., Gabelica, Z. and Blom, N., “Synthesis and Characterization of ZSM-5 type Zeolites, 1. Physico-Chemical Properties of Precursors and Intermediates”,Appl. Catal.,1, 201 (1981).
Fajula, F. and Plee, D., “Application of Molecular Sieves in View of Cleaner Technology. Gas and Liquid separation”, in Jansen, J. C., Stcker, M., Karge, H. G. and Weikamp, J. (Eds.), “Advanced Zeolite Science and Applications”,Stud. Surf. Sci. Catal.,85, 587 (1994).
Feijen, E. J. P., Martens, J. A. and Jacobs, P. A., “Zeolites and their Mechanism of Synthesis”, in Weitkamp, J., Karge, H. G., Pfeifer, H. and Holderich, W. (Eds.), “Zeolites and Related Microporous Materials: State of the Art 1994”,Stud. Surf. Sci. Catal.,84, 3 (1994).
Fukui, K. and Nishida, S., “CO Gas Sensor Based on Au-LaO Added SnO Ceramics with Siliceous Zeolite Coat;Sensors and Actuators B,45, 101 (1997).
Iler, R. K., “The Chemistry of Silica: Solubility, Polymerization, Colloid and Surface Properties, and Biochemistry”, John Wiley & Sons, New York (1972).
Jacobs, P. A., Derouane, E. G. and Weitkamp, J., “Evidence for X-ray Amorphous Zeolites”,J. Chem. Soc. Chem. Commun., 591 (1981).
Jansen, J. C., Engelen, C. W. R. and van Bekkum, H., “Crystal Growth Regulation and Morphology of Zeolite Single Crystals of the MFI Type”, in M. L. Occelli and H. E. Robson (Eds.), “Zeolits Synthsis”, ACS Symp. Ser., Am. Chem. Soc., Washington, DC,398, 257 (1989).
Jansen, J. C., “The Preparation of Molecular Sieves, A. Synthesis of Zeolites”, in van Bekkum, H., Flanigen, E. M. and Jansen, J. C. (Eds.), “Introduction to Zeolite Science and Practice”, Stud. Surf. Sci. Catal.,58, 77 (1991).
Kim, G.-J., Ahn, W.-S., Cho, B.-R. and Kwon, L.-M., “Synthesis of ZSM-5 and Silicalite-I (II)-Effect of pH on Crystallization”,HWAHAKKONGHAK,27, 198, (1989).
Kim, W. J., Lee, M. C., Kim, J. W. and Ha, J. M., “The Crystallization of ZSM-5 at Low Temperature and Atmospheric Pressure”,J. of Korean Ind. & Eng. Chem.,8, 320 (1997).
Kim, W. J. and Lee, M. C., “The Effect of Various Alkali Cations on the Crystallization of ZSM-5 at Atmospheric Pressure and Low Temperature”,J. of Korean Ind & Eng. Chem.,9, 38 (1998).
Kim, W. J., Lee, M. C. and David, H. T., “Synthesis of ZSM-5 at Low Temperature and Atmospheric Pressure in a Pilot-scale Batch Reactor”,Micropor. Mesopor. Mater,26, 133 (1998).
Kiyozumi, Y., Shin, S., Shul, Y.-G., Ihm, S.-K. and Koo, K.-K., “Crystal Growth of High Silica ZSM-5 at Low Temperature Synthesis Conditions”,Korean J. Chem. Eng.,13, 144 (1996).
Oh, H.-S., Kim, M.-H. and Rhee, H.-K., “Synthesis of Zeolite Membrane on the Inner Surface of a Ceramic Tube”, in Chon, H., Ihm, S.-K. and Uh, Y. S. (Eds.), “Progress in Zeolite and Microporous Materials”,Stud. Surf. Sci. Catal.,105, 2217 (1997).
Park, J.-W., Hahm, H.-S., Kim, J.-W, Ha, J.-M. and Park, H.-Y, “Physico-Chemical Characteristics of the ZSM-5 Crystallized at Atmospheric Pressure and Conversion of Propene on the ZSM-5”,HWAHAK KONGHAK,36, 369 (1998).
Perez-Pariente, J., Martens, J. A. and Jacobs, P. A., “Characterization of Intermediate TPA-ZSM-5 type Structures During Crystallization”,Appl. Catal,31, 35 (1987).
Scholle, K. F. M. G. J., Veeman, W. S., Frenken, P. and van der Velden, G. P. M., “Crysatffization Mechanism of Zeolite Beta from (TEA)2O, Na2O, and K2O Containing Aluminosilicate Gels”,Appl. Catal.,17, 233 (1985).
Sie, S. T., “tPast, Present and Future Role of Microporous Catalysts in the Petroleum Industry”, in Jansen, J. C., Stcker, M., Karge, H. G. and Weikamp, J. (Eds.), “Advanced Zeolite Science and Applications”,Stud. Surf. Sci. Catal.,85, 587 (1994).
Szostak, R., “Molecular Sieves: Principles of Synthesis and Identification”, Van Nostrand Rhinhold, New York (1989).
Testa, F., Szostak, R., Chiappetta, R., Aiello, R., Fonseca, A. and Nagy, J. B., “Crystallization of MFI and MEL Zeolites from Clear Solutions”,Zeolites,18, 106 (1997).
van de Graaf, J. M., Kaptenijn, F. and Moulijn, J. A., “Methodological and Operational Aspects of Permeation Measurements on Silicalite-1 Membranes”,J. Membr. Sci.,144, 87 (1998).
van Hoff, J. H. C. and Roelofsen, J. W., “Techniques of Zeolite Characterization”, in van Bekkum, H., Flanigen, E. M. and Jansen, J. C., (Eds.), “Introduction to Zeolite Science and Practice”,Stud. Surf. Sci. Catal.,58, 241 (1991).
Yi, K.-H. and Ihm, S.-K. “Crystallization Mechanism for Atmospheric Synthesis of High Silica ZSM-5”,Microporous Materials,1, 115 (1993).
Woo, M.-U., Kim, M.-H., Rhee, H.-K. and Lee, W.-Y., “Synthesis and Characterization of ZSM-5 Zeolite Catalyst”,HWAHAK KONGHAK,25, 427 (1987).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Oh, HS., Kang, KK., Kim, MH. et al. Synthesis of MFI-type zeolites under atmospheric pressure. Korean J. Chem. Eng. 18, 113–119 (2001). https://doi.org/10.1007/BF02707207
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02707207