Abstract
Success of adsorbed natural gas (ANG) storage process is mainly based on the characteristics of the adsorbent, so various synthesized adsorbents were analyzed for methane adsorption on a thermodynamic basis. Activated carbon from rice husk (AC-RH) was synthesized and its methane adsorption capacities were compared with phenol based activated carbons (AC-PH2O and AC-PKOH). The adsorption experiments were conducted by volumetric method under various constant temperatures (293.15, 303.15, 313.15 and 323.15 K) and pressure up to 3.5MPa. Maximum methane adsorption was observed in AC-RH as its surface area is higher than the other two adsorbents. The experimental data were correlated well with Langmuir-Fruendlich isotherms. In addition, isosteric heat of adsorption was calculated by using Clausius-Clapeyron equation.
Article PDF
Similar content being viewed by others
Explore related subjects
Discover the latest articles, news and stories from top researchers in related subjects.Avoid common mistakes on your manuscript.
References
Basumatary, R., Dutta, P., Prasad, B. and Srinivasan, K., “Thermal modeling of activated carbon based adsorpative natural gas storage system,”Carbon,43, 541 (2005).
Belmabkhout, Y., Frere, M. and DeWeireld., “High-pressure adsorption measurements. A comparative study of the volumetric and gravimetric methods,”Meas. Sci. Technol.,15, 848 (2004).
Burchell, T. D.,Carbon materials for advanced technologies, Pergamon, Oxord (1999).
Burchell, T. and Rogers, M., SEA Paper No. 2000-01-2205, Pub. Society of Automotive Engineers, Inc. (2000).
Choi, B.-U., Choi, D.-K., Lee, Y.-W. and Lee, B.-K., “Adsorption equilibria of methane, ethane, ethylene, nitrogen, and hydrogen on to activated carbon,”J. Chem. Eng. Data,48, 603 (2003).
Choi, B.-U., Nam, G.-M., Choi, D.-K., Lee, B.-K., Kim, S.-H. and Lee, C.-H., “Adsorption and regeneration dynamics characteristics of methane and hydrogen binary system,”Korean J. Chem. Eng.,21, 821 (2004).
Cracknell, R. F., Gordon, P. and Gubbins, K. E., “Influence of pore geometry on the design of microporous materials for methane storage,”J. Phys. Chem.,97, 494 (1993).
Dubinin, M.M., “The potential theory of adsorption of gases and vapors for adsorbents with energetically nonuniform surfaces,”Chem. Rev.,60, 235 (1960).
Hill, T. L., “Statistical mechanics of adsorption. V. Thermodynamics and heat of adsorption,”J. Chem. Phys.,17, 520 (1949).
Jaroneic, M., Lu, X. C. and Madey, R., “Use of polynomial equation for analysing low concentration adsorption measurements of ethane on activated carbon,”Sep. Sci. Tech.,24, 1355 (1990).
Jian Sun, Mark, J. R., Massoud, R.-A. and Anthony, A. L., “Natural gas storage with activated carbon from a bituminous coal,”Gas. Sep. Purif.,10, 91 (1996).
Linares-Solano, V., “Advances in the study of methane storage in porous carbonaceous materials,”Fuel,81, 1777 (2002).
Lozano-Castello, D., Lillo-Rodenas, M. A., Cazorla-Amoros, D. and Linares-Solano, A., “Preparation of activated carbons from spanish anthracite. I. Activation by KOH,”Carbon,39, 741 (2001).
Lozano-Castello, D., Cazorla-Amoros, D. and Linares-Solano, A., “Powdered activated carbons and activated carbon fibers for methane storage: A comparative study,”Energy & Fuels,16, 1321 (2002).
Kim, B.-H., Kum, G.-H. and Seo, Y.-G., “Adsorption of methane and ethane into single-walled carbon nannotubes and slit-shaped carbonaceous pores,”Korean J. Chem. Eng.,20, 104 (2003).
MacDonald, J. A. F. and Quinn, D. F., “Carbon adsorbents for natural gas storage,”Fuel,77, 61 (1998).
Malek, A. and Farooq, S., “Comparison of isotherm models for hydrocarbon on activated carbon,”AIChE J.,42, 3191 (1996).
Menon, V. and Kormarnei, S., “Porous adsorbents for vehicular natural gas storage: A review,”J. Porous. Mater.,5, 43 (1998).
Perrin, A., Celzard, A., Albiniak, A., Jasienko-Halat, M., Mareche, J. F. and Furdin, G., “NaOH activation of anthracites: Effect of hydroxide content on pore textures and methane storage ability,”Micropor. Mesopor. Mater.,81, 31 (2005).
Quinn, D. F. and MacDonald, J. A., “Natural gas storage,”Carbon,30, 097 (1992).
Mota, J. P. B., “Impact of gas composition on natural gas storage by adsorption,”AIChE J.,45, 986 (1999).
Nguyen, D. M. and Do, D. D., “Adsorption of supercritical gases in porous media: determination of micropore size distribution,”J. Phys. Chem. B.,103, 690 (1999).
Shuji, H., Toshiya, K. and Shoichi, F., “High-pressure adsorption equilibrium of methane and carbon dioxide on several activated carbons,”J. Chem. Eng. Data,50, 369 (2005).
Sircar, S., Golden, T. C. and Rao, M. B., “Activated carbon for gas separation and storage,”Carbon,34, 1 (1996).
Wegrzyn, J. and Gurevich, M., “Adsorbent storage of natural gas,”Applied Energy,55, 71 (1996).
Yang, R.T.,Gas separation by adsorption processes, Butterworths Publishers, Stoneham (1987).
Zhou, L., Zhou, Y., Ming, L. and Wang, Y., “Experimental and modeling study of the adsorption of supercritical methane on a high surface activated carbon,”Langmuir,16, 5955 (2000).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Balathanigaimani, M.S., Kang, HC., Shim, WG. et al. Preparation of powdered activated carbon from rice husk and its methane adsorption properties. Korean J. Chem. Eng. 23, 663–668 (2006). https://doi.org/10.1007/BF02706811
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02706811