Abstract
The separation process of synthesizing MIBK (methyl isobutyl ketone) by an isopropanol one-step method, in which the multi-component mixture contains AC (acetone), IPA (isopropanol), water, MIBK, MIBC (methyl isobutyl carbinol), DIBK (di-isobutyl ketone), etc., was studied. As a high-purity of MIBK over 99.5 wt% is required in industry, the development of an effective separation method is urgent. In this work, first, by means of VLE (vapor-liquid equilibrium) experiments and PROII simulation, the possible azeotropes formed in the investigated system were tested. Then, the separation process was simulated with the result that the calculated and designed values were in good agreement, which indicated that the calculated results were reliable. On this basis, the original separation process was improved. In the original separation process, the yield of MIBK for a concentration of MIBK over 99.5 wt% was small, only 32.5%. In the improved separation process (step two), two columns (one extractive distillation column and the other solvent recovery column) were added and some simplification was made so as to recycle MIBK. In this case the yield of MIBK was 91.7%. Moreover, about 27.6% water stream per kilogram MIBK product is saved.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Arlt, W., Spuhl, O. and Klamt, A., “Challenges in thermodynamics,”Chem. Eng. Proc.,43, 221 (2004).
Blanco, B., Sanz, M. T., Beltran, S., Cabezas, J. L. and Coca, J., “Vaporliquid equilibria for the ternary system benzene+n-heptane+N,N-dimethylformamide at 101.33 kPa,”Fluid Phase Equilib.,175, 117 (2000).
Chen, L. L.,Solvent handbook, Chemical Industry Press, Beijing (1997).
Cosimo, J. I. D., Torres, G. and Apesteguia, C. R., “One-step MIBK synthesis: a new process from 2-propanol,”J. Catal.,208, 114 (2002).
Ko, M. S., Na, S., Cho, J. and Kim, H., “Simulation of the aromatic recovery process by extractive distillation,”Korean J. Chem. Eng.,19, 996 (2002).
Lei, Z. G., Wang, H. Y., Zhou, R. Q. and Duan, Z. T., “Influence of salt added to solvent on extractive distillation,”Chem. Eng. J.,87, 149 (2002a).
Lei, Z. G., Zhou, R. Q. and Duan, Z. T., “Process improvement on separating C4 by extractive distillation,”Chem. Eng. J.,85, 379 (2002b).
Lei, Z. G., Li, C. Y. and Chen, B. H., “Extractive distillation: a review,”Sep. Purif. Rev.,32, 121 (2003a).
Lei, Z. G., Li, C. Y. and Chen, B. H., “Comments on the paper ’simulation of the aromatic recovery process by extractive distillation’ (Ko, M., Na, S., Cho, J. and Kim, H.,Korean J. Chem. Eng., 19,996 (2002),” Korean J. Chem. Eng., 20,1077 (2003b).
Lei, Z. G., Chen, B. H. and Ding, Z. W.,Special distillation processes, Elsevier, Amsterdam, 1 (2005).
Li, J. W., Lei, Z. G., Ding, Z. W., Li, C. Y. and Chen, B. H., “Azeotropic distillation: a review of mathematical models,”Sep. Purif. Rev.,34, 87 (2005a).
Li, J. W., Lei, Z. G., Li, C. Y. and Chen, B. H., “Comments on special distillation processes,”Korean J. Chem. Eng.,22, 617 (2005b).
Liang, C., “Production and market analysis of methyl isobutyl ketone,”Mod. Chem. Ind. (China),19(9), 36 (1999).
Lin, K. H. and Ko, A. N., “Na Promotion of Pd/MgO catalysts for lowpressure one-step synthesis of MIBK from acetone+H2,”Appl. Catal. A-Gen.,147, L259 (1996).
Mattos, L. V., Noronha, F. B. and Monteiro, J. L. F., “Bifunctional metal/ base catalysts (Pt/X) for the direct synthesis of MIBK from acetone,”J. Catal.,209, 166(2002).
Mulas, G., Deledda, S. and Cocco, G., “The mechanochemical conversion of acetone to methyl isobutyl ketone over Cu-Mg based substrates,”Mater. Sci. Eng. A-Struct. Mater. Prop. Microstruct. Process,267, 214(1999).
Narayanan, S. and Unnikrishnan, R., “Selective hydrogenation of acetone to methyl isobutyl ketone (MIBK) over Co-precipitated Ni/ Al2O3 catalysts,”Appl. Catal. A-Gen.,145, 231 (1996).
Resa, J. M., Gonzalez, C., Betolaza, M. A. and Ruiz, A., “Behaviour of butyl ether as entrainer for the extractive distillation of the azeotropic mixture propanone+dissopropyl ether. isobaric VLE data of the azeotropic components with the entrainer,”Fluid Phase Equilib.,156, 89 (1999).
Wang, X. Q., “Production technology and application of methyl isobutyl ketone,”Petrochem. Technol. (China),31, 393 (2002).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Lei, Z., Li, J., Li, C. et al. Improvement of separation process of synthesizing MIBK by the isopropanol one-step method. Korean J. Chem. Eng. 23, 264–270 (2006). https://doi.org/10.1007/BF02705725
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02705725