Abstract
The solubility of three disperse anthraquinone dyes and two azo dyes in supercritical CO2 was measured. The tested dyes are Celliton fast blue B, l-amino-2-methylanthraquinone, 1-methylaminoanthraquinone, disperse Red 1 and 4-[4-(phynylazo)phenylazo]-o-cresol. Solubility measurements were made at 313.15-393.15 K and 10-25 MPa in a high-temperature autoclave phase equilibrium apparatus. Pure physical properties of the dyes such as critical constants, molar volumes and vapor pressures were estimated based on semi-empirical methods. Also, the data were quantitatively modeled by both an empirical density correlation and a quantitative equation of state recently proposed by the present authors based on nonrandom lattice theory. We found that anthraquinone disperse dyes in general show higher solubility than azo disperse dyes in supercritical CO2 within the experimental ranges.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Bartle, K. D., Clifford, A. A. and Jafar, S. A., “Solubilities of Solids and Liquids of Low Volatility in Supercritical Carbon Dioxide”,J. Phys. Chem. Ref. Data,20, 713 (1991).
Chiou, J. S., Barlow, J. W. and Paul, D. R., “Plasticization of Glassy Polymers by CO2”,J. of Applied Polymer Sci.,30, 2633 (1985).
Chiou, J. S., Maeda, Y. and Paul, D. R., “Gas and Vapor in Polymers Just Below Tg”,J. Applied Polymer Sci.,30, 4019 (1985).
Chang, K. H., Bae, H. K. and Shim, J. J., “Dyeing of PET Textile Fibers and Films in Supercritical Carbon Dioxide”,Korean J. Chem. Eng.,13(3), 310 (1996).
Fleming, G. K. and Koros, W. J., “Dilation of Polymers by Sorption of Carbon Dioxide at Elevated Pressures”,Macromolecules,19, 2285 (1986).
Gebert, B., Saus, W., Knittel, D., Buschmann, H. J. and Schollmeyer, E., “Dyeing Natural Fibers with Disperse Dyes in Supercritical Carbon Dioxide”,Textile Res. J.,64(7), 371 (1994).
Knittel, D., Saus, W. and Schollmeyer, E., “Application of Supercritical Carbon Dioxide in Finishing Processes”,J. of the Textile Institute,84, 534 (1993).
Lyman, W. J., Reehl, W. F. and Rosenblatt, D. H., HANDBOOK OF CHEMICAL PROPERTY ESTIMATION METHODS, American Chemical Society, Washington, DC, 1990.
özcan, A. S., Clifford, A. A. and Bartle, K. D, “Solubility of Disperse Dyes in Supercritical Carbon Dioxide”,J. Chem. & Eng. Data,42, 590 (1997).
Reid, R. C., Prausnitz, J. M. and Poling, B. E., “The Properties of Gases & Liquids”, 4th Ed., McGraw Hill, New York, 1987.
Saus, W., Knittel, D. and Schollmeyer, E., “Dyeing of Textiles in Supercritical Carbon Dioxide”,Textile Res. J.,63(3), 135 (1993).
Swidersky, P., Haarhaus, U., Tuma, P. and Schneider, G. M., “High-pressure Investigations on the Solubility of Organic Dyes in Supercritical Gases by Vis/Nir Spectroscopy”, Korean J. Chem. Eng. (Vol. 15, No. 1) Proc. of 3rd Int. Supercritical Fluids (Strasbourg, France, 17–19 October, 1994), 191 (1994).
Timmermans, J., Physico-Chemical Constants of Pure Organic Compounds, Vol. 1 and Vol. 2, Elsevier Scientific Publishing Company, New York, 1950.
You, S. S., Yoo, K.-P. and Lee, C. S., “An Approximate Nonrandom Lattice Theory of Fluids. General Derivation and Application to Pure Fluids”,Fluid Phase Equil,93, 193 (1994a).
You, S. S., Yoo, K.-P. and Lee, C. S., “An Approximate Nonrandom Lattice Theory of Fluid Mixtures”,Fluid Phase Equil,93, 215 (1994b).
You, S. S., Yoo, S. J., Yoo, K.-P. and Lee, C. S., “Multiphase Behavior and Critical Loci in Binary Mixtures Using A New Equation of State Based on the Nonrandom Lattice-Fluid Theory”,J. Supercritical Fluids,7, 251 (1994c).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Joung, S.N., Shin, H.Y., Park, Y.H. et al. Measurement and correlation of solubility of disperse anthraquinone and azo dyes in supercritical carbon dioxide. Korean J. Chem. Eng. 15, 78–84 (1998). https://doi.org/10.1007/BF02705309
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02705309