Abstract
An experiment for five stages of a biofilter-run was performed to investigate the effect of hydrophilic ethanol and hydrophobic toluene on the biodegradation of hydrophobic toluene and hydrophilic ethanol, respectively, when waste-air containing toluene and ethanol was treated by a biofilter. Removal efficiencies of toluene and ethanol began to decrease when inlet load surpassed 90 g/m3/h and 100 g/m3/h consistent with maximum elimination capacities of toluene and ethanol, respectively. At the end of the biofilter-run, removal efficiencies for toluene and ethanol were decreased and maintained at 65% and 40%, respectively. The concentration of toluene at 1st sampling port was raised by factor of two in the 3rd stage of the biofilter run when the inlet load of ethanol co-feed was increased by 1.5 times, while the process conditions of toluene were maintained the same as those of the 2nd stage of biofilter-run. According to the result of Mohseni and Allen, it may be interpreted that removal efficiency of hydrophobic toluene was affected by the presence of hydrophilic ethanol when high load of hydrophobic toluene was applied like that of the 1st sampling port of the biofilter. However it was not the case when a low load of hydrophobic toluene was applied like those of the 2nd, 3rd and 4th sampling ports since hydrophobicity of toluene is much less that of α-pinene. Thus, it may be suggested that biodegradation of hydrophobic VOC was interfered by hydrophilic VOC dissolved in the biolayer and the degree of interference was proportional to the inlet load of hydrophobic VOC as well as that of hydrophilic VOC and was inversely proportional to the solubility of hydrophobic VOC. However, it was inferred that the existence of hydrophobic toluene from waste-air can hardly inversely hinder the removal of hydrophilic ethanol in the biofilter when timeevolutions of hydrophilic ethanol concentrations of this experiment were compared with those of the previous experiment of biofilter to treat waste-air containing ethanol only.
Article PDF
Explore related subjects
Discover the latest articles, news and stories from top researchers in related subjects.Avoid common mistakes on your manuscript.
References
Arulneyam, D. and Swaminathan, T., “Biodegradation of Ethanol Vapor in a Biofilter,”Bioproc. Eng.,22, 63 (2000).
Auria, R., Aycaguer, A. C. and Devinny, J. S., “Influence of Water Content on Degradation Rates for Ethanol in Biofiltration,”J. Air Waste Manag. Assoc.,48, 65 (1998).
Bohn, H. L.,Soil Treatment of Organic Waste Gases, Soils for Management of Organic Wastes and Wastewaters, ASA-CSSA-SSSA, Madison, WI, pp. 607–618 (1977).
Buchner, R.,Auswirkungen Verschiedener Betriebszustande in der Biologischen Abluftreinigung am Beispiel von Biofiltern, Ph. D. Thesis, T. U. Wien, Austria (1989).
Christine, P., Domenech, F., Michelena, G., Auria, R. and Revah, S., “Biofiltration of Volatile Ethanol using Sugar Cane Bagasse Inoculated withCandida utilis,”Journal of Hazardous Materials,B89, 253 (2002).
Deshusses, M.A., Hamer, G. and Dunn, I. J., “Behaviour of Biofilters for Waste Air Biotreatment. 1. Dynamic Model Develpement,”Environ. Sci. Technol.,29, 1048 (1995).
Deshusses, M. A. and Dunn, I. J.,Modelling Experiments on the Kinetics of Mixed-solvent Removal from Waste Gas in a Biofilter, Proceedings of the 6th European Congress on Biotechnology (L. Alberghina, L. Frontali and P. Sensi eds.), Elsevier Science B. V., 1191–1198 (1994).
Deshusses, M.A. and Hamer, G., “The Removal of Volatile Ketone Mixtures from Air in Biofilters,”Bioprocess Engineering,9, 141 (1993).
Hodge, D. S. and Devinny, J. S., “Biofilter Treatment of Ethanol Vapors,”Environmental Progress, 13(3), 167 (1994).
Hodge, D. S. and Devinny, J. S., “Modeling Removal of Air Contaminants by Biofiltration,”Journal of Environmental Engineering, 121(1), 21 (1995).
Jorio, H., Kiared, K., Brezenski, R., Leroux, A., Viel, G. and Heitz, M., “Treatment of Air Polluted with High Concentrations of Toluene and Xylene in a Pilot-scale Biofilter,”J. Chem. Technol. Biotechnol.,73, 183 (1998).
Leson, G. and Winer, A.M., “Biofiltration: An Innovative Air Pollution Control Technology for VOC Emissions,”J. Air & Waste Manage. Assoc.,41, 1045 (1991).
Leson, G. and Smith, B. J., “Petroleum Environmental Research Forum Field Study on Biofilters for Control of Volatile Hydrocarbons,”Journal of Environmental Engineering, 123(6), 556 (1997).
Lim, K. H. and Lee, E. J., “Biofilter Modeling for Waste Air Treatment: Comparisons of Inherent Characteristics of Biofilter Models,”Korean J. Chem. Eng., 20(2), 315 (2003).
Lim, K.H. and Park, S.W., “The Treatment of Waste-air Containing Mixed Solvent using a Biofilter; 1. Transient Behavior of Biofilter to Treat Wasye-air Containing Ethanol,”Korean J. Chem. Eng., 21(6), 1161 (2004).
Lim, K.H. and Park, S.W., “Treatment of Mixed Solvent with Hybrid System Composed of Biofilter and Photo-catalytic Reactor,”Korean J. Chem. Eng., 22(1), 70 (2005).
Mohseni, M. and Allen, D.G., “Biofiltration of Mixtures of Hydrophilic and Hydrophobic Volatile Organic Compounds,”Chemical Engineering Science,55, 1545 (2000).
Ottengraf, S. P. P.,Exhaust Gas Purification, Biotechnology (H. J. Rehm, G. Reed, eds.), VCH, Weinheim, Germany, Vol. 8, pp. 426–452 (1986).
Ottengraf, S. P. P. and van den Oever, A.H. C., “Kinetics of Organic Compound Removal from Waste Gases with a Biological Filter,”Biotechnology and Bioengineering,25, 3089 (1983).
Shim, J. S., Jung, J. T., Sofer, S. and Lakhwala, F., “Oxidation of Ethanol Vapors in a Spiral Bioreactor,”J. Chem. Technol. Biotechnol.,64, 49 (1995).
Sorial, G.A., Smith, F. L., Suidan, M. T. and Biswas, P., “Evaluation of Trickle Bed Biofilter Media for Toluene Removal,”Journal of the Air & Waste Management Association,45, 801 (1995).
Swanson, W. J. and Loehr, R.C., “Biofiltration: Fundamentals, Design and Operations Principles, and Applications,”Journal of Environmental Engineering, 123(6), 538 (1997).
Tang, B., Hwang, S. J. and Hwang, S., “Dynamics of Toluene Degradation in Biofilters,”Hazardous Waste & Hazardous Materials, 12(3), 207 (1995).
William, T. O. and Miller, F. C., “Biofilters and Facility Operations,”Biocycle,33, 75 (1992).
Zarook, S. M. and Baltzis, B.C., “Biofiltration of Toluene Vapor Under Steady-state and Transient Conditions: Theory and Experimental Results,”Chemical Engineering Science,49, 4347 (1994).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Lim, KH. The treatment of waste-air containing mixed solvent using a biofilter 2. Treatment of waste-air containing ethanol and toluene in a biofilter. Korean J. Chem. Eng. 22, 228–233 (2005). https://doi.org/10.1007/BF02701489
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02701489