Abstract
The use of hydroxylated chloromethylated-styrene/divinylbenzene copolymer as a support for three different catalysts, Cp2ZrCl2, [Ind]2ZrCl2 and (CH3)2Si[Ind]2ZrCl2 has been examined for the polymerization of ethylene in gas phase. The gas phase polymerization experiments were performed in a horizontal reactor by using Box-Behnken experimental design [Box and Wilson, 1951] to study the effects of temperature, ethylene partial pressure, and MAO cocatalyst level on polymerization. The measured average catalyst activities were empirically correlated with these three factors. Temperature appears to be the most important factor, which shows a first and second order effect on activity and also interacts with pressure and MAO. The kinetic study shows that these supported catalysts might contain two types of active sites, and the deactivation of sites follows a first order kinetic.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Box, C. E. P. and Wilson, K. P., “On the Experimental Attainment of Optimum Conditions,”J. Roy. Stat. Soc. B13, 1 (1951).
Chung, J. S. and Hsu, J.C., “A Kinetic Analysis on the Gas Phase Polymerization of Ethylene over Polymer Supported (CH3)2Si[Ind]2ZrCl2 Catalyst,”Polymer,43, 1307 (2002).
Dumas, C. and Hsu, C. C., “Propylene Polymerization in a Semi Batch Slurry Reactor over Supported TiCl4/MgCl2/Ethyl Benzoate/Triethyl Aluminum Catalyst, II. A Kinetic Study Based on a Multisite Model,”J. Appl. Polym. Sci. 37, 1625 (1989).
Kim, J.D., Soares, B. P. and Rempel, G. L., “Synthesis of Tailor-Made Polyethylene through the Control of Polymerization Conditions Using Selectively Combined Metallocene Catalysts in a Supported System,”J. Polym. Sci, Part A: Polym. Chem. 37, 331(1999).
Soga, K. and Kaminaka, M., “Polymerization of Propene with the Heterogeneous Catalyst System Et[IndH4]2ZrCl2/MAO/SiO2 Combined with Trialkylaluminum,”Macromol. Rapid Commun.,13, 221 (1992).
Soga, K. and Kaminaka, M., “Polymerization of Olefins with SiO2/-, Al2O3/- and MgCl2-Supported Metallocene Catalysts Activated by Trialkylaluminums,”Macromol. Chem. Phys. 195, 1369 (1994).
Tairova, G., Zhang, Y., McAuley, K. B. and Bacon, D.W., “Development of Polymer Supported Metallocene Catalysts for Gas Phase Olefin Polymerization,” Final Report to ESTAC, Queen’s University (1999).
Tait, P. T. T. and Wang, S., “Studies on the Polymerization of Propylene Using Highly Active Ziegler-Natta Catalyst, I: Kinetic Models for Rate Decay in Ziegler-Natta Polymerization,”Brit. Polym. J. 20, 499 (1988).
Author information
Authors and Affiliations
Corresponding author
Additional information
This paper is dedicated to Professor Wha Young Lee on the occasion of his retirement from Seoul National University.
Rights and permissions
About this article
Cite this article
Chung, J.S., Tairova, G., Zhang, Y. et al. Polymer-supported metallocene catalysts for gas-phase ethylene polymerization. Korean J. Chem. Eng. 19, 597–600 (2002). https://doi.org/10.1007/BF02699302
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02699302