Abstract
Conversion of methane to C2/C3 or higher hydrocarbons in a pulsed DC barrier discharge at atmospheric pressure was studied. Non-equilibrium plasma was generated in the barrier discharge reactor. In this plasma, electrons which had sufficient energy collided with the molecules of methane, which were then activated and coupled to C2/C3 or higher hydrocarbons. The effect of the change of applied voltage, pulse frequency and methane flow rate on methane conversion, selectivities and yields of products was studied. Methane conversion to higher hydrocarbons was about 25% as the maximum. Ethane, propane and ethylene were produced as primary products, including a small amount of unidentified C4 hydrocarbons. The selectivity and yield of ethane as a main product came to about 80% and 17% as the highest, respectively. The selectivities of ethane and ethylene were influenced not by the change of pulse frequency but by the change of applied voltage and methane flow rate. However, in case of propane, the selectivity was independent of those condition changes. The effect of the packing materials such as glass and A12O3 bead on methane conversion was also considered, showing that A12O3 played a role in enhancing the selectivity of ethane remarkably as a catalyst.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Bae, Y. K., Jun, J. H. and Yoon, K. J.,“Qxidative Coupling of Methane over Promoted Strontium Chlorapatite,”Korean J. Chem. Eng.,16, 595 (1999).
Caldwell, T. A., Poonphatanaricha, P., Chavadej, S., Mallinson, R. G. and Lobban, L. L.,“Third-Body Enhanced Methane Conversion in a Dielectric-Barrier Discharge Reactor,”216th ACS National Meeting; Division of Fuel Chemistry,43, 490 (1998).
Chang, J. S., Lawless, P. A. and Yamamoto, T.,“Corona Discharge Processes,”IEEE Trans. Plasma Sci.,19, 1152 (1991).
Cho, W., Baek, Y., Pang, H. and Kim, Y. C.,“A Direct Catalytic Conversion of Natural Gas to C2+Hydrocarbons by Microwave Plasma,”Korean J. Chem. Eng.,15, 500 (1998).
Fischer, F. and Pichler, H.,“Üer die Thermische Zersetzung von Methan,”Brennst-Chem.,13(20) 381 (1932).
Fraser, M. E., Fee, D. A. and Sheinson, R. S.,“Decomposition of Methane in an AC Discharge,”Plasma Chem. Plasma Process,5, 163 (1985).
Holmen, A., Olsvic, O. and Rokstad, O. A. “Tyrolysis of Natural Gas: Chemistry and Process Concepts,”Fuel Processing Technology,42, 249 (1995).
Ito, T., Wang, J. X., Lin, C. H. and Lunsford, J. H.,“Qxidative Dimerization of Methane over a Lithium-Promoted Magnesium Oxide Catalyst,”J. Am. Chem. Soc.,107, 5062 (1988).
Lee, D. C., Whang, M. H.,“High Voltage Plasma Engineering,” Dongil, Seoul (1994).
Lin, C. H., Wang, J. X. and Lunsford, J. H.,“Oxidative Dimerization of Methane over Sodium-Promoted Calcium Oxide,”J. Catal.,111, 302 (1988).
Liu, C., Mallinson, R. and Lobban, L.,“Nonoxidative Methane Conversion to Acetylene over Zeolite in a Low Temperature Plasma,”J. Catal.,179, 326 (1998).
Liu, C., Marafee, A., Hill, B., Xu, G., Mallinson, R. and Lobban, L.,“Oxidative Coupling of Methane with ac and dc Corona Discharge,”Ind. Eng. Chem. Res.,35, 295 (1996).
Liu, C., Marafee, A., Mallinson, R. and Lobban, L.,“Methane Conversion to Higher Hydrocarbons over Metal Oxide Catalysts with OH Groups,”Appl. Catal. A: General,164, 21 (1997).
Marafee, A., Liu, C., Xu, G., Mallinson, R. and Lobban, L.,“An Experimental Study on the Oxidative Coupling of Methane in a Direct Current Corona Discharge Reactor over Sr/La2O3 Catalyst,”Ind. Eng. Chem. Res.,36, 632 (1997).
Oumghar, A., Legrand, J. C., Diamy, A. M. and Turillon, N.,“Methane Conversion by an Air Microwave Plasma,”Plasma Chem. Plasma Process.,5, 87 (1995).
Savinov, S. Y., Lee, H., Song, H. K. and Na, B. K.,“A Study on Decomposition of Methane and Carbon Dioxide in a Radio-Frequency Discharge,”Ind. Eng. Chem. Res.,38(7), 2540 (1999).
Sofranko, J. A., Leonard, J. J. and Jones, C. A.,“The Oxidative Conversion of Methane to Higher Hydrocarbon,”J. Catal.,103, 302 (1987).
Thanyachotpaiboon, K., Chavadej, S., Caldwell, T. A., Lobban, L. L. and Mallinson, R. G.,“Conversion of Methane to Higher Hydrocarbons in AC Nonequilibrium Plasmas,”AIChE J.,44, 2252 (1998).
Wheeler, R. V. and Wood, W L.,“The Pyrolysis of Methane,”Fuel,7, 535 (1928).
Zhang, H. S., Wang, J. X., Driscoll, D. J. and Lunsford, J. H.,“Activation and Oxidative Dimerization of Methane over Lithium-Promoted Zinc Oxide,”J. Catal.,112, 366 (1988).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Jeong, HK., Kim, SC., Han, C. et al. Conversion of methane to higher hydrocarbons in pulsed DC barrier discharge at atmospheric pressure. Korean J. Chem. Eng. 18, 196–201 (2001). https://doi.org/10.1007/BF02698459
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02698459