Abstract
The newly designed wetted-wick column was constructed by using fiber glass and wire mesh and studied to investigate its feasibility as an alternative to the conventional packed tower in gas purification processes.
Absorption of carbon dioxide in water for physical absorption and in aqueous mono-ethanolamine (MEA) solution for chemical absorption were employed for this investigation. A comparison with the packed tower, based on overall mass transfer coefficients (KOGa) and height of transfer units (HTUOG) at the same range of operating conditions, feed gas compositions, and gas retention time was made. High mass transfer coefficients (KOGa) and low heights of transfer unit (HTUOG) were obtained for the wetted-wick column. The high efficiency of mass transfer was caused by a number of factors: the separate passage of liquid and gas flow, an increased wetting surface, a longer period of residence time of the liquid and gas stream, and an increased interfacial area.
The present study shows that the wetted-wick column is a highly recommendable device as an alternative to the packed tower in gas purification processes, either for physical gas absorption or for chemical gas absorption.
Article PDF
Similar content being viewed by others
Explore related subjects
Discover the latest articles, news and stories from top researchers in related subjects.Avoid common mistakes on your manuscript.
References
Kohl, A.L. and Riesenfeld, F.C.: “Gas Purification”, Gulf Publishing Co. Book Division, Houston, 3rd ed. (1979).
Mohr, V.H. and Rangke, G.:Chem. Eng. Prog., October,22 (1984).
Butwell, K.F., Kubek, D.J., and Sigmund, P.W..Chem. Eng. Prog.,75 (2), 75 (1979).
Eckert, J.S.:Chem. Eng. Prog.,57 (9), 54 (1961).
Eckert, J.S.:Chem. Eng. Prog.,59 (5), 76 (1963).
Gupta, A.S. and Thodos, G.:Chem. Eng. Prog.,58 (7), 58 (1962).
Gupta, A.S. and Thodos, G.:Chem. Eng. Prog.,58(10), 62(1962).
Leva, M., Lucas, J.M., and Frahme, H.H.:Ind. Eng. Chem.,46 (6), 1255 (1954).
Chen, B.H. and Jain, S.C.:Can. J. of Chem. Eng,,58, 281 (1980).
Niranjan, K., Sawant, S.B., Joshi, J.B., and Pangarkar, V.G.:Chem. Eng. Sci.,37 (3), 367 (1982).
Manning, R.E. and Cannon, MR.:Ind. Eng. Chem.,49, 347 (1957).
Platt, Trans. Inst. Chem. Engrs. (London),29, 226 (1951).
Ryan, J.F.: “Factors Affecting Fractionation in Packed Column”, Ph.D. Thesis, Pennsylvania State Univ., University Park, PA (1953).
Roblee, L.H.S., Baird, R.M., and Tierney, J.W.:AIChE J.,4, 460(1958).
Ridgeway, K. and Tarbuck, K.J.:Brit. Chem. Engr.,12, 384(1967).
Pillai, K.K.:Chem. Eng. Sci.,32, 59 (1977).
Porter, K.E. and Templeman, J.J.:Trans. Inst. Chem. Engrs.,46, T86 (1968).
Huber, M. and Hiltbrunner, R.:Chem. Eng. Sci.,21, 819(1966).
Zenz, F.A.:Chem. Eng.,79(25), 120(1972).
Vermeulen, T.J., Moon, J.S., Hennico, A., and Miyauchi, T.:Chem. Eng. Prog.,62(9), 95 (1966).
Shah, Y.T., Stiegel, G.J., and Sharma, M.M.:AIChE J.,24 (3), 369(1978).
Sherwood, T.K., Pigford, R.L., and Wilke, C.R.: “Mass Transfer”, McGraw-Hill Kogakusa, Ltd., Page 615 (1975).
Eastman, G.Y. and Ernst, D.M.: “Heat Pipe”, Encyclopedia of Chemical Technology, 3rd ed., Vol.12, 191 (1980).
Dunn, P.D. and Reay, D.A.: “Heat Pipes”, 3rd Ed., Pergamon Press (1982).
Seok, D.R. and Hwang, ST.:AIChEJ., 31(12), 2059(1985).
Cantelo, R.C., Simmons, C.W., Giles, E.M., and Brill, F.A.:Ind. Eng. Chem.,19 (9), 989 (1927).
Buch, K.:Soc. Sci. Fennica Commentationes Phys. Math., 2(16), 1 (1925).
Morgan, O.M. and Maass, O.:Can. J. Research,5, 162(1931).
Dodds, W.S., Stutzman, L.F., and Sollami, B.J.:Chem. Eng. Data,1(1), 92 (1956).
Allen, H.V.: “Absorption of Carbon Dioxide in Aqueous Solutions”, M.S. Thesis, MIT (1938).
Sherwood, T.K. and Holloway, F.A.L.:Trans. Am. Inst. Chem. Engrs.,36, 89 (1940).
Cooper, C.M., Christl, R.J., and Peery, L.C.:Trans. Am. Inst. Chem. Engrs.,37, 979 (1941).
Kent, R.L. and Eisenberg, B.: Equilibrium of H2S and CO2 with MEA and DEA Solutions”, Gas Conditioning Conference Proc., 1975.
Mason, J.W. and Dodge, D.F.:Trans. Am. Inst. Chem. Engrs.,32(1), 27 (1936).
Teller, A.J. and Ford, H.E.:Ind. Eng. Chem.,50(8), 1201 (1958).
Cryder, D.S. and Malonehy, J.O.:Trans. Amer. Inst. Chem. Engrs.,37, 827 (1941).
McCabe, W.L., Smith, J.C., and Harriott, P.: “Unit Operations of Chemical Engineering”, 4th ed., McGraw-Hill Book Co. (1985).
Chilton, T.H. and Colburn, A.P.:Ind. Eng. Chem.,27(3), 255 (1935).
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Lee, KR., Hwang, ST. Gas absorption with wetted-wick column. Korean J. Chem. Eng. 6, 259–269 (1989). https://doi.org/10.1007/BF02697689
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02697689