Abstract
The catalytic activity behavior for the selective catalytic reduction of NO by C3H6 under excess oxygen and the nature of surface species on the active sites of Pt/Al2O3 catalyst after adding a second metal (Fe, Sn, Co, Cr or W) were investigated. It has been found that an important role of second metals is on TONs of C3H6 and NO conversions and the nature of surface species produced on the catalyst surface at low temperature instead of the catalytic activity behavior towards the temperature programmed reaction. Although the introduction of each second metal distinctly disturbs the characteristic of surface species, the reaction mechanism is presumably similar. The observation of few surface species and the investigation about their reactivity indicate that few mechanisms are simultaneously proceeding at the same reaction condition.
Article PDF
Similar content being viewed by others
Explore related subjects
Discover the latest articles, news and stories from top researchers in related subjects.Avoid common mistakes on your manuscript.
References
Bamwenda, G. R., Ogata, A., Obuchi, A., Oi, J., Mizuno, K. and Skrzypek, J., “Selective Reduction of Nitric Oxide with Propene over Platinum-group Based Catalysts: Studies of Surface Species and Catalytic Activity,”Appl. Catal. B,6, 311 (1995).
Bensaddik, A., Mouaddib, N., Krawczyk, M., Pitchon, V., Garin, F. and Maire, G., “Promoting Effect of Zinc in DeNOx Reaction over Pt/ Al2O3,”Stud. Surf. Sci. Catal.,116, 265 (1998).
Burch, R., Millington, P. J. and Walker, A. P., “Mechanism of the Selective Reduction of Nitrogen Monoxide on Platinum-based Catalysts in the Presence of Excess Oxygen,”Appl. Catal. B,4, 65 (1994).
Burch, R., Shestov, A. A. and Sullivan, J. A., “A Transient Kinetic Study of the Mechanism of the NO/C3H6/O2 Reaction over Pt-SiO2 Catalysts,”J. Catal.,182, 497 (1999).
Burch, R., Sullivan, J. A. and Watling, T. C., “Mechanistic Considerations for the Reduction of NOx over Pt/Al2O3 and Al2O3 Catalysts under Lean-burn Conditions,”Catal. Today,42, 13 (1998).
Burch, R. and Watling, T.C., “The Effect of Promoters on Pt/Al2O3 Catalysts for the Reduction of NO by C3H6 under Lean-burn Conditions,”Appl. Catal. B,11, 207 (1997).
Captain, D.K. and Amiridis, M.D., “In Situ FTIR Studies of the Selective Catalytic Reduction of NO by C3H6 over Pt/Al2O3,”J. Catal.,184, 377 (1999).
Captain, D.K., Roberts, K. L. and Amiridis, M.D., “The Selective Catalytic Reduction of Nitric Oxide by Propylene over Pt/SiO2,”Catal. Today,42, 93 (1998).
Eckhoff, S., Hesse, D., van den Tillaart, J.A.A., Leyrer, J. and Lox, E. S., “Mechanistic Investigation on the Selective Reduction of NO with Propene in the Presence of Oxygen over Supported Platinum,”Stud. Surf. Sci. Catal.,116, 223 (1997).
Engler, B. H., Leyrer, J., Lox, E. S. and Ostgathe, K., “Catalytic Reduction of Nitrogen Oxides in Diesel Exhaust Gas,”Stud. Surf. Sci. Catal.,96, 529 (1994).
Fritz, A. and Pitchon, V., “The Current State of Research on Automotive Lean NOx Catalysis,”Appl. Catal. B,13, 1 (1997).
Lacombe, S., Hoebink, J. H. B. J. and Marin, G. B., “Platinum Catalyzed Reduction of Nitric Oxide by N-butane in the Presence of Oxygen: Role of the Hydrocarbon,”Appl. Catal. B,12, 207 (1997).
Nikolopoulos, A.A., Stergioula, E. S., Efthimiadis, E. A. and Vasalos, I. A., “Selective Catalytic Reduction of NO by Propene in Excess Oxygen on Pt- and Rh-supported Alumina Catalysts,”Catal. Today,54, 439 (1999).
Obuchi, A., Ohi, A., Nakamura, M., Ogata, A., Mizuno, K. and Ohuchi, H., “Performance of Platinum-group Metal Catalysts for the Selective Reduction of Nitrogen Oxides by Hydrocarbons,”Appl. Catal. B,2, 71 (1993).
Okuhara, T., Hasada, Y. and Misono, M., “In Situ Diffuse Reflectance IR of Catalytic Reduction of Nitrogen Oxides by Propene in the Presence of Oxygen over Silica-supported Platinum,”Catal. Today,35, 83 (1997).
Rottlander, C., Andorf, R., Plog, C., Krutzsch, B. and Baerns, M., “Selective NO Reduction by Propane and Propene over a Pt/ZSM-5 Catalyst: a Transient Study of the Reaction Mechanism,”Appl. Catal. B,11, 49 (1996).
Sasaki, M., Hamada, H., Kintaichi, Y. and Ito, T., “Role of Oxygen in Selective Reduction of Nitrogen Monoxide by Propane over Zeolite and Alumina-based Catalysts,”Catal. Lett.,15, 297 (1992).
Tanaka, T., Okuhara, T. and Misono, M., “Intermediacy of Organic Nitro and Nitrite Surface Species in Selective Reduction of Nitrogen Monoxide by Propene in the Presence of Excess Oxygen over Silicasupported Platinum,”Appl. Catal. B,4, L1 (1994).
Tanaka, T., Yokota, K., Isomura, N., Doi, H. and Sugiura, M., “Effect of the Addition of Mo and Na to Pt Catalysts on the Selective Reduction of NO,”Appl. Catal. B,16, 199 (1998).
Xin, M., Hwang, I.C. and Woo, S. I., “FTIR Studies of the Reduction of Nitric Oxide by Propene on Pt/ZSM-5 in the Presence of Oxygen,”J. Phys. Chem.,101, 9005 (1997).
Xin, M., Hwang, I. C. and Woo, S. I., “In Situ FTIR Study of the Selective Catalytic Reduction of NO on Pt/ZSM-5,”Catal. Today,38, 187 (1997).
Zhang, G., Yamaguchi, T., Kawakami, H. and Suzuki, T., “Selective Reduction of Nitric Oxide over Platinum Catalysts in the Presence of Sulfur Dioxide and Excess Oxygen,”Appl. Catal. B,1, L15 (1992).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Praserthdam, P., Chaisuk, C. & Mongkhonsi, T. The nature of surface species on modified Pt-based catalysts for the SCR of NO by C3H6 under lean-burn condition. Korean J. Chem. Eng. 20, 32–38 (2003). https://doi.org/10.1007/BF02697181
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02697181