Abstract
Potato chips were fried in six canola (low-erucic acid rape-seed) oils under pilot-plant process settings that represented commercial conditions. Oil samples included an unmodified canola oil and oils with fatty acid compositions modified by mutation breeding or hydrogenation. Chips were fried for a 2-d, 18-h cycle for each oil. Chips and oil were sampled periodically for sensory, gas-chromatographic volatiles and chemical analyses. Unmodified canola oil produced chips with lower flavor stability and oxidative stability than the other oils. The hydrogenated oil imparted a typical hydrogenation flavor to the chips that slightly affected overall quality. the modified canola oil (IMC 129) with the highest oleic acid level (78%) had the lowest content of total polar compounds and the lowest total volatile compounds at most of the storage times; however, the sensory quality of the potato chip was only fair. The potato chip with the best flavor stability was fried in a modified/blended oil (IMC 01-4.5/129) with 68% oleic acid, 20% linoleic acid and 3% linolenic acid.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Cowan, J.C., C.D. Evans, H. Moser, G.R. List, S. Koritala, K.J. Moulton and H.J. Dutton,J. Am. Oil Chem. Soc. 47:470 (1970).
Cowan, J.C., H. Moser, G.R. List and C.D. Evans, ——Ibid. 48:835 (1971).
Cowan, J.C., S. Koritala, K. Warner, G.R. List, K.J. Moulton and C.D. Evans, ——Ibid. 50:132 (1973).
Wilson, R.F., J.W. Burton and P. Kwanyuen, inEdible Fats and Oils Processing: Basic Principles and Modern Practices, edited by D. Erickson, American Oil Chemists' Society, Champaign, 1989, pp. 355–359.
Mounts, T.L., K. Warner, G.R. List, R. Kleiman, E.G. Hammond and J.R. Wilcox,J. Am. Oil Chem. Soc. 65:624 (1988).
Miller, L.A., and P.J. White, ——Ibid. 65:1324 (1988).
Liu, H., and P.J. White, ——Ibid., 69:533 (1992).
Fuller, G., G.O. Kohler and T.H. Applewhite, ——Ibid., 43:477 (1966).
Purdy, R.H., and B.J. Campbell,Fd. Tech. 21:349 (1967).
Fuller, G., M.J. Diamond and T.H. Applewhite,J. Am. Oil Chem. Soc. 44:264 (1967).
Fuller, G., D.G. Guadagni, M.L. Weaver, G. Notter and R.J. Horvat,J. Food Sci. 36:43 (1971).
Warner, K., C.D. Evans, G.R. List, B.K. Boundy and W.F. Kwolek, ——Ibid., 39:761 (1974).
Anon.,Snack World 48:S-W6 (1991).
Lulai, E.C., and P.H. Orr,Am. Potato J. 57:622 (1980).
Waltking, A.E., and H. Wessels,J. Assoc. Off. Anal. Chem. 64:1329 (1981).
Official Methods and Recommended Practices of the American Oil Chemists' Society, 4th edn., Champaign, 1989.
Orr, P.H., and K.G. Janardan,Am. Potato J. 67:647 (1990).
Snedecor, G.W.,Statistical Methods, 5th edn., Iowa State University Press, Ames, 1956.
Author information
Authors and Affiliations
About this article
Cite this article
Warner, K., Orr, P., Parrott, L. et al. Effects of frying oil composition on potato chip stability. J Am Oil Chem Soc 71, 1117–1121 (1994). https://doi.org/10.1007/BF02675905
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02675905