Abstract
Thermal behavior of palm oil samples drawn from the batch crystallizers that failed during crystallization and of a control oil that was drawn from a batch that produced good crystallization were analyzed by differential scanning calorimetry under constant heating and cooling conditions. Four polymorphs—β’2, α, β’1, and β1—were observed, and their temperatures were tabulated. A rapid and sudden surge of heat demand was observed for samples from failed crystallizers. Less supercooling values were obtained from the control oil compared to the higher values for samples from failed crystallizers. In crystallization thermograms, a sharp high-temperature exotherm (high-T peak) and a broad low-temperature exotherm (low-T peak) were observed. Low-T peaks were found almost invariably stationary at −5.1 to −5.6°C, and high-T peaks varied depending on the saturation level of the oil. A new peak, sandwiched between the high-T and low-T peaks, was observed for the control oil.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Jurriens, G.,Analysis and Characterization of Oils, Fats and Fat Products, Vol. 2, Interscience, London, 1968, pp. 25–34.
Weiss, T.J.,Food Oils and Their Uses, 2nd edn., AVI Publishing Co., Westport, 1983, p. 19.
Deffense, E.,J. Am. Oil Chem. Soc. 62:376–385 (1985).
Ng, W.L., Ibid.:879–882 (1990).
Watanabe, A., I. Tashima, N. Matsuzaki, J. Kurashige, and K. Sato, Ibid.:1077–1080 (1992).
Jacobsberg, B., and O.C. Ho, Ibid.:609–617 (1976).
Riiner, U.,Lebensm.-wiss. & Technologie 4:76–84 (1971).
Persmark, U., K.A. Melin, and P.O. Stahl,Rev. Ital. Del. Sos. Gra. 53:301–306 (1976).
Okiy, D.A.,Oleagineux 33:625–628 (1978).
Kawamura, K.,J. Am. Oil Chem. Soc. 56:753–758 (1979).
Rossell, J.B., Ibid.:505–511 (1975).
Taylor, A.M.,Oleagineux 31:73–79 (1976).
Kawamura, K.,J. Am. Oil Chem. Soc. 57:48–52 (1980).
van Putte, K.P.A.M., and B.H. Bakker, Ibid.:1138–1143 (1987).
Ng, W.L., and F.C.H Oh, inThe Proceedings of the PORIM International Palm Oil Conference, September 9–14, 1991, Kuala Lumpur, Malaysia, 1991, pp. 298–304.
Jacobsberg, B., and D. Jacqmain, inThe Proceedings of the Malaysian International Symposium on Palm Oil Processing and Marketing, June 17–19, 1976, Kuala Lumpur, Malaysia, 1976, pp. 143–147.
Author information
Authors and Affiliations
About this article
Cite this article
Man, Y.B.C., Swe, P.Z. Thermal analysis of failed-batch palm oil by differential scanning calorimetry. J Am Oil Chem Soc 72, 1529–1532 (1995). https://doi.org/10.1007/BF02577848
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02577848