Abstract
The chemical composition of the Soranovskii Miscanthus variety harvested in 2011 and 2012 was separately determined in the whole plant, leaves, and stem. In all cases, cellulose was found to prevail in the Miscanthus stem, and noncellulosic components (the fat-wax fraction, ash, and lignin), in leaves. Cellulose samples were for the first time obtained from leaves and stems separately by two methods (nitric-acid and combined). The best quality cellulose was derived from stems. For instance, cellulose isolated from stems by the nitric-acid process was better than that from leaves, which was expressed as a higher cellulose content (94.4% versus 91.7%) and degree of polymerization (800 versus 580), as well as low weight fractions of noncellulosic components: ash (0.07% versus 1.01%) and acid-insoluble lignin (0.45% versus 1.51%). The same tendency is observed in celluloses produced by the combined method: Cellulose from stems had better quality than that from leaves; specifically, it had higher degree of polymerization (1040 versus 640) and lower weight fractions of the noncellulosic components: ash (0.14% versus 0.75%), acid-insoluble lignin (0.88% versus 4.12%), and pentosans (6.38% versus 8.53%). It is obvious that cellulose obtained by the nitric-acid method can be suitable for chemical modifications, including nitration. Cellulose from the combined process can be utilized in paper industry.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Brosse, N., Dufour, A., Meng, X., Sun, Q., and Ragauskas, A., Miscanthus: a fast-growing crop for biofuels and chemicals production, Biofuels, Bioprod., Bioref., 2012, vol. 6,iss. 5, pp. 580–598. DOI: 10.1002/bbb
Budaeva, V.V., Mitrofanov, R.Yu., Zolotukhin, V.N., and Arkhipova, O.S., Properties of Miscanthus pulp, Polzunovskii Vestnik, 2010, no. 3, pp. 240–245.
Budaeva, V.V., Mitrofanov, R.Yu., Zolotukhin, V.N., and Sakovich, G.V., New sources of raw materials of pulp for technical chemistry, Vestn. Kazan. Tekhnol. un-ta, 2011, no. 7, pp. 205–212.
Bulatkin, G.A. and Mitenko, G.V., Promising energy culture—Chinese Miscanthus, Ekol. Vestn. Rossii, 2013, no. 7, pp. 31–36.
Gismatulina, Yu.A., Budaeva, V.V., and Zolotukhin, V.N., Obtaining and properties of pulp suitable for nitration, in Perspektivy sozdaniya i primeneniya kondensirovannykh vysokoenergeticheskikh materialov: Dokl. IV Nauch.-Tekhn. Konf. molodykh uchenykh, Biisk, 27–28 sentyabrya 2012 (Prospects of Development and Application of High-Energy Condensed Materials: Proc. IV Sci.-Engin. Conf. Young Scientists, Biisk, September 27–28, 2012), Biisk: Izd. Alt. Gos. Tekhn. Univ., 2012, pp. 27–28.
GOST 10820-75. Tsellyuloza. Metod opredeleniya massovoi doli pentozanov. Izd. ofitsial’noe (Cellulose. Method for Determination of Mass Fraction of Pentosan. Official Edition), Moscow: Izd. Standartov, 1991.
GOST 25438-82. Tsellyuloza dlya khimicheskoi pererabotki. Metody opredeleniya kharakteristicheskoi vyazkosti. Izd. ofitsial’noe (Pulp for Chemical Processing. Methods for Determination of Intrinsic Viscosity. Official Edition), Moscow: Izd. Standartov, 1982.
GOST 30418-96. Masla rastitel’nye. Metod opredeleniya zhirnokislotnogo sostava. Izd. ofitsial’noe (Vegetable Oils. Method for Determination of Fatty Acid Composition. Official Edition), Minsk: Mezhgos. Sovet po standartizatsii, metrologii i sertifikatsii, 1998.
GOST 595-79. Tsellyuloza khlopkovaya. Tekhnicheskie usloviya. Izd. ofitsial’noe (Cotton Pulp. Technical Conditions. Official Edition), Moscow: Izd. Standartov, 2002.
State register of breeding achievements permitted for use, Miscanthus variety Soranovskii, no. 8854628, 2013. http://www.gossort.com/reestr/new-sort.html
Ivanov, S.N., Tekhnologiya bumagi (Paper Technology), 3rd ed., Moscow: Shkola bumagi, 2006.
Jones, M.B., Miscanthus: For Energy and Fibre, Published by Earthscan, 2001.
Krotkevich, P.G., Shumeiko, K.I., Voloshina, L.A., Nesterchuk, E.N., and Petrun’, I.I., Morphological characteristics and chemical composition of Miscanthus sinensis Anderss. as a raw material for pulp and paper industry, Rastit. Resursy, 1983, vol. 19, no. 3, pp. 321–323.
Lend’el, P. and Morvai, Sh., Khimiya i tekhnologiya tsellyuloznogo proizvodstva (Chemistry and Technology of Pulp Production), Tishchenko, A.F., Ed., Moscow: Lesn. Prom., 1978.
Nikitin, N.I., Khimiya drevesiny i tsellyulozy (Wood and Pulp Chemistry), Moscow: Izd. AN SSSR, 1962.
Novyi spravochnik khimika i tekhnologa. Syr’e i produkty promyshlennosti organicheskikh i neorganicheskikh veshchestv. Ch. II (A New Handbook of Chemist and Technologist: Raw Materials and Industrial Products of Organic and Inorganic Substances. Part II), St. Petersburg: NPO Professional, 2006.
Obolenskaya, A.V., El’nitskaya, Z.P., and Leonovich, A.A., Laboratornye raboty po khimii drevesiny i tsellyulozy (Laboratory Works on the Chemistry of Wood and Pulp), Moscow: Ekologiya, 1991.
Shakhmina, E.V., Adaptation of new pulp feedstock to the technologies of chemical industry, in Sovremennye problemy tekhnicheskoi khimii: Mater. dokl. Vseros. nauch.-tekhn. konf., Kazan’, 21–23 noyabrya 2003 (Modern Problems of Technical Chemistry: Proc. All-Russia Sci.-Techn. Conf., Kazan, November 21–23, 2003), Kazan, 2003, pp. 231–232.
Shumnyi, V.K., Veprev, S.G., Nechiporenko, N.N., Goryachkovskaya, T.N., Slyn’ko, N.M., Kolchanov, N.A., and Pel’tek, S.E., A new form of Chinese Miscanthus (Chinese silver grass, Miscanthus sinensis Anderss.) as a promising source of cellulosic feedstock, Vavilov. Zh. Genet. Selekts., 2010, vol. 14, no. 1, pp. 122–126.
Somerville, C., Youngs, H., Taylor, C., Davis, S.C., and Long, S.P., Feedstocks for lignocellulosic biofuels, Science, 2010, vol. 329, pp. 790–792.
Sun, R.C., Cereal Straw As a Resource for Sustainable Biomaterials and Biofuels—Chemistry, Extractives, Lignins, Hemicelluloses and Cellulose, Elsevier, 2010.
Tkacheva, N.I., Morozov, S.V., and Grigor’ev, I.A., Mognonov, D.M., Modification of cellulose—a promising direction in the development of new materials, Vysokomol. Soed. Ser. B, 2013, vol. 55, no. 8, pp. 1086–1107. DOI: 10.7868/S0507547513070179
Villaverde, J.J., Domingues, R.M.A., Freire, C.S.R., Silvestre, A.J.D., Pascoal, NetoC., Ligero, P., and Vega, A., Miscanthus giganteus extractives: a source of valuable phenolic compounds and sterols, J. Agric. Food Chem., 2009, vol. 57, no. 9, pp. 3626–3631.
Yakusheva, A.A., Nitrates of cellulose from Russia Miscanthus, in Tekhnologii i oborudovanie khimicheskoi, biotekhnologicheskoi i pishchevoi promyshlennosti: Mater. 5-i Vseros. nauch.-prakt. konf. studentov, aspirantov i molodykh uchenykh s mezhdunarodnym uchastiem, Biisk, 24–26 maya 2012 (Technology and Equipment of Chemical, Biotechnological, and Food Industries: Proc. 5th All-Russia Sci. Pract. Conf. of Students, Graduate Students, and Young Scientists with International Participation, Biisk, May 24–26, 2012), Biisk: Izd. Alt. Gos. Tekhn. Univ., 2012, pp. 24–26.
Yakusheva, A.A., Properties of nitrocelluloses from cotton and oat shells, Polzunovskii Vestnik, 2013, no. 3, pp. 202–206.
Zhegrov, E.F., Milekhin, Yu.M., and Berkovskaya, E.V., Khimiya i tekhnologiya ballistitnykh porokhov, tverdykh raketnykh i spetsial’nykh topliv (Chemistry and Technology of Ballistic Powders, Solid Rocket Fuels, and Special Fuels), Vol. 2: Tekhnologiya (Technology), Moscow: RITs MGUP im. I. Fedorova, 2011, pp. 57–59.
Author information
Authors and Affiliations
Corresponding author
Additional information
Original Russian Text © Yu.A. Gismatulina, V.V. Budaeva, S.G. Veprev, G.V. Sakovich, V.K. Shumny, 2014, published in Vavilovskii Zhurnal Genetiki i Selektsii, 2014, Vol. 18, No. 3, pp. 553–563.
Rights and permissions
About this article
Cite this article
Gismatulina, Y.A., Budaeva, V.V., Veprev, S.G. et al. Cellulose from various parts of Soranovskii Miscanthus . Russ J Genet Appl Res 5, 60–68 (2015). https://doi.org/10.1134/S2079059715010049
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1134/S2079059715010049