Abstract
The hardness and Young’s modulus of the thin hydroxyapatite-based coatings deposited by RF magnetron sputtering onto magnesium alloy, titanium, and steel substrates are studied. As the penetration depth increases, the hardness and Young’s modulus of these coatings are found to tend toward the values that are characteristic of the substrates. It is shown that the difference between the values of hardness and Young’s modulus at small penetration depths (h < 80–100 nm) can be caused by the difference between the physicomechanical properties inside the coatings and that this difference at large penetration depths (h > 100 nm) can be induced by an additional effect of the strength properties of the substrate material.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
M. Epple and R. A. Surmenev, RSC Adv. 3, 11057 (2013).
K. Anselme, Osteoporosis Int. 22, 2037 (2011).
M. P. Staiger, A. M. Pietak, J. Huadmai, and G. Dias, Biomaterials 27, 1728 (2006).
R. A. Surmenev, M. A. Surmeneva, and A. A. Ivanova, Acta Biomater. 10, 557 (2014).
S. Shadanbaz and G. J. Dias, Acta Biomater. 8, 20 (2012).
M. A. Surmeneva, M. V. Chaikina, V. I. Zaikovskiy, V. F. Pichugin, V. Buck, O. Prymak, M. Epple, and R. A. Surmenev, Surf. Coat. Technol. 218, 39 (2013).
M. A. Surmeneva, A. Kovtun, A. Peetsch, S. N. Goroja, A. A. Sharonova, V. F. Pichugin, I. Y. Grubova, A. A. Ivanova, A. D. Teresov, N. N. Koval, V. Buck, A. Wittmar, M. Ulbricht, O. Prymak, M. Epple, and R. A. Surmenev, RSC Adv. 3, 11240 (2013).
D. S. Syromotina, M. A. Surmeneva, S. N. Gorodzha, V. F. Pichugin, A. A. Ivanova, I. Yu. Grubova, K. S. Kravchuk, K. V. Gogolinskii, O. Prymak, M. Epple, and R. A. Surmenev, Russ. Phys. J. 56, 1198 (2014).
B. Bhushan, Springer Handbook of Nanotechnology (Springer, Berlin, 2010).
A. C. Fischer-Cripps, Nanoindentation (Springer, New York, 2011).
Yu. I. Golovin, Nanoindention and Its Potential (Mashinostroenie, Moscow, 2009).
M. A. Surmeneva, A. I. Tyurin, T. M. Mukhametkaliyev, T. S. Pirozhkova, I. A. Shuvarin, M. S. Syrtanov, and R. A. Surmenev, J. Mech. Behav. Biomed. Mater. 46, 127 (2015).
M. A. Surmeneva, R. A. Surmenev, A. I. Tyurin, T. M. Mukhametkaliyev, A. D. Teresov, N. N. Koval, T. S. Pirozhkova, I. A. Shuvarin, and C. Oehr, Thin Solid Films 571, 218 (2014).
S. D. Viktorov, Yu. I. Golovin, A. N. Kochanov, A. I. Tyurin, A. V. Shuklinov, I. A. Shuvarin, and T. S. Pirozhkova, Fiz.-Tekh. Probl. Razrab. Polezn. Iskop., No. 4, 46 (2014).
M. Sh. Akchurin, R. V. Gainutdinov, E. A. Garibin, Yu. I. Golovin, A. A. Demidenko, K. V. Dukel’skii, S. V. Kuznetsov, I. A. Mironov, V. V. Osiko, A. N. Smirnov, N. Yu. Tabachkova, A. I. Tyurin, P. P. Fedorov, and V. V. Shindyapin, Perspekt. Mater., No. 5, 5 (2010).
Yu. I. Golovin, A. I. Tyurin, and V. V. Khlebnikov, Tech. Phys. 50, 479 (2005).
Yu. I. Golovin, A. I. Tyurin, and B. Ya. Farber, Philos. Mag. A 82, 1857 (2002).
V. A. Khonik, Yu. I. Golovin, V. I. Ivolgin, A. I. Tyurin, and K. Kitagawa, Scripta Mater. 45, 947 (2001).
Yu. I. Golovin and A. I. Tyurin, Materialovedenie, No. 1, 14 (2001).
Yu. I. Golovin and A. I. Tyurin, Izv. Ross. Akad. Nauk, Ser. Fiz. 59 (10), 49 (1995).
A. R. Shugurov, A. V. Panin, and K. V. Oskomov, Phys. Solid State 50, 1050 (2008).
V. F. Pichugin, R. A. Surmenev, E. V. Shesterikov, M. A. Ryabtseva, E. V. Eshenko, S. I. Tverdokhlebov, O. Prymak, and M. Epple, Surf. Coat. Technol. 202, 3913 (2008).
W. C. Oliver and G. M. Pharr, J. Mater. Res. 7, 1564 (1992).
W. C. Oliver and G. M. Pharr, J. Mater. Res. 19, R3 (2004).
Y. Huang, F. Zhang, K. C. Hwang, and W. D. Nix, J. Mech. Phys. Solids 49, 1997 (2001).
F. Zhang, R. Saha, Y. Huang, W. D. Nix, K. C. Hwang, S. Qu, and M. Li, Int. J. Plast. 23 (1), 25 (2007).
B. Bhushan, J. Colloid Interface Sci. 367 (1), 1 (2012).
R. Saha and W. D. Nix, Acta Mater. 50 (1), 23 (2002).
G. Abadias, S. Dub, and R. Shmegera, Surf. Coat. Technol. 200, 6538 (2006).
Y. T. Pei, G. M. Song, W. G. Sloof, and J. Th. M. De Hosson, Surf. Coat. Technol. 201, 6911 (2007).
M. A. Surmeneva, R. A. Surmenev, Yu. A. Nikonova, I. I. Selezneva, A. A. Ivanova, V. I. Putlyaev, O. Prymak, and M. Epple, Appl. Surf. Sci. 317, 172 (2014).
M. A. Surmeneva, R. A. Surmenev, V. F. Pichugin, N. N. Koval’, A. D. Teresov, A. A. Ivanova, I. Yu. Grubova, V. P. Ignatov, O. Primak, and M. Epple, Poverkhnost, No. 10, 32 (2013).
Author information
Authors and Affiliations
Corresponding author
Additional information
Original Russian Text © M.A. Surmeneva, R.A. Surmenev, A.I. Tyurin, T.S. Pirozhkova, I.A. Shuvarin, 2016, published in Zhurnal Tekhnicheskoi Fiziki, 2016, Vol. 86, No. 9, pp. 89–95.
Rights and permissions
About this article
Cite this article
Surmeneva, M.A., Surmenev, R.A., Tyurin, A.I. et al. Nanoindentation of a hard ceramic coating formed on a soft substrate. Tech. Phys. 61, 1370–1376 (2016). https://doi.org/10.1134/S1063784216090279
Received:
Published:
Issue Date:
DOI: https://doi.org/10.1134/S1063784216090279