Abstract
Experimental study of evacuated tubes coupled solar still in the climatic conditions of Mehsana, a region of North Gujarat, India during summer and winter climate conditions has been made. Experimental setup was made by authors. Fourteen double-walled hard borosilicate glass tubes have been used. Evacuated tubes were inclined at angle of 45° from horizontal. Outer tubes of evacuated tubes were transparent, inner tubes were coated with a selective coating of Al-Ni/Al compound for better solar radiation absorption and minimum emittance. It has been shown that evacuated tube attachments to the solar still increased the water temperature inside the solar still for increment in the generation of distillate output. Evacuated tubes coupled solar still is not only produce distilled water during sunshine hours, but also off-sunshine hours due to heat storage effect. For the validation of the experimental results, a theoretical model is proposed based on the fundamentals of heat and mass transfer equations for solar still glass cover, water in basin and basin bottom. Two main statistical parameters—root mean square error and mean bias error—were calculated to compare the results of experiments and theoretical analysis. Closed matching of the experimental and theoretical results has been found.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
K. Sampathkumar, T. V. Arjunan, M. Eswaramoorthy, and P. Senthilkumar, “Thermal modeling of a solar still coupled with evacuated tube collector under natural circulation mode—an experimental validation,” Energy Sources, Part A 35 (15), 1441–1455 (2013).
H. N. Panchal and P. K. Shah, “Enhancement of upper basin distillate output by attachment of vacuum tubes with double-basin solar still,” Desalin. Water Treat. 55 (3), 587–595 (2015).
H. N. Panchal and P. K. Shah, “Effect of varying glass cover thickness on performance of solar still: in a winter climate conditions,” Int._J. Renewable Energy Res. 1 (4), 212–223 (2012).
B. S. Shobha, W. Vilas, and A. M. Rajesh, “Performance evaluation of a solar still coupled to an evacuated tube collector type solar water heater,” Int. J. Innovations Eng. Technol. 1 (1), 72–84 (2012).
J. Xiong, G. Xie, and H. Zheng, “Experimental and numerical study on a new multi-effect solar still with enhanced condensation surface,” Energy Convers. Manage. 73 (1), 176–185 (2013).
Z. M. Omara, M. A. Eltawil, El S. A. El Nashar, “A new hybrid desalination system using wicks/solar still and evacuated solar water heater,” Desalination 325 (1), 56–64 (2013).
H. Abad Kargar Sharif, M. Ghiasi, Mamouri S. Jahangiri, and M. B. Shafii, “A novel integrated solar desalination system with a pulsating heat pipe,” Desalination 311 (1), 206–210 (2013).
H. N. Panchal, “Experimental analysis of different absorber plates on performance of double slope solar still,” Int. J. Eng. Sci. Technol. 2 (11), 6626–6629 (2010).
H. Panchal, “Experimental investigation of varying parameters affecting on double slope single basin solar still,” Int. J. Adv. Eng. Sci. 1 (2), 17–21 (2011).
H. N. Panchal, M. Doshi, P. Chavda, R. Goswami, “Effect of cow dung cakes inside basin on heat transfer coefficients and productivity of single basin single slope solar still,” Int. J. Appl. Eng. Res., Dindigul 1 (4), 675–690 (2010).
H. N. Panchal, M. Doshi, A. Patel, and K. Thakor, “Experimental investigation on coupling evacuated glass tube collector on single slope single basin solar still productivity,” Int. J. Mech. Eng. Technol. 2 (1), 1–9 (2011).
H. N. Panchal, M. I. Patel, B. Patel, R. Goswami, and M. Doshi, “A comparative analysis of single slope solar still coupled with flat plate collector and passive solar still,” Int. J. Res. Rev. Appl. Sci. 7 (2), 111–116 (2011).
H. N. Panchal and P. K. Shah, “Charperformance analysis of different energy absorbing plates on solar stills,” Iran. J. Energy Environ. 2 (4), 297–301 (2011).
H. Panchal and P. K. Shah, “Modelling and verification of single slope solar still using ANSYS-CFX,” Int._J. Energy Environ. 2 (6), 985–998 (2011).
H. Panchal and P. K. Shah, “Investigation on solar stills having floating plates,” Int. J. Energy Environ. Eng. 3 (1), 8 (2012).
H. N. Panchal and P. K. Shah, “Experimental and ANSYS CFD simulation analysis of hemispherical solar still,” IIRE Int. J. Renewable Energy 8 (1), 1–14 (2013).
H. N. Panchal and P. K. Shah, “Modeling and verification of hemispherical solar still using ANSYS CFD,” Int. J. Energy Environ. 4 (3), 427–440 (2013).
H. N. Panchal and P. K. Shah, “Performance improvement of solar stills via experimental investigation,” Int. J. Adv. Des. Manuf. Technol. 5 (5), 19–23 (2012).
H. N. Panchal and P. K. Shah, “Performance analysis of double basin solar still with evacuated tubes,” Appl. Sol. Energy 49 (3), 174–179 (2013).
H. N. Panchal and P. K. Shah, “Enhancement of distillate output of double basin solar still with vacuum tubes,” Front. Energy 8 (1), 101–109 (2014).
H. N. Panchal and P. K. Shah, “Investigation on performance analysis of a novel design of the vacuum tubeassisted double basin solar still: An experimental approach,” Int. J. Ambient Energy 37 (3), 220–226 (2016).
N. S. Thakar, H. N. Panchal, and V. N. Thakkar, “Performance analysis of various parameters on glass cover of solar distiller–Experimental study,” Int. J. Adv. Eng. Res. Dev. 1 (3), 231–242 (2014).
Author information
Authors and Affiliations
Corresponding author
Additional information
Published in Russian in Teploenergetika.
The article is published in the original.
Rights and permissions
About this article
Cite this article
Panchal, H.N., Thakkar, H. Theoretical and experimental validation of evacuated tubes directly coupled with solar still. Therm. Eng. 63, 825–831 (2016). https://doi.org/10.1134/S0040601516110045
Published:
Issue Date:
DOI: https://doi.org/10.1134/S0040601516110045