Abstract
Electrodes should be adhered onto the body steadily under motion, and implanted stably into the tissue without any damages while maintaining conformal contact. Although most electrodes are fabricated with biocompatible materials, they should be shielded from tissues to prevent mechanical delamination from the device itself and to avoid adverse effects such as irritation, allergic reactions, or inflammation. Herein, we demonstrate a simple process for the development of a flexible and implantable capacitive electrode based on a minimal incision accessible design with polyimide (PI) and Gold/Titanium (Au/Ti) layers and completely encapsulated in a polydimethylsiloxane (PDMS) substrate. Electrodes of three different sizes (recording site diameters of 1.8 mm, 2.8 mm, and 3.8 mm, respectively) were fabricated and examined in this work. Electrocardiography (ECG) was recorded in the dorsal area of the rat for 4 weeks for biological signal checkup. We obtained stable and robust ECG signals owing to the intrinsic property of capacitive coupling, with almost no leakage current compared to the direct contact electrode for the applied current over the range of 0 to 10 mA. These results indicate that our electrode can be used to detect bio-signals effectively in the long term, and can play a role in electroceuticals in the near future.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Arzbaecher, R., Hampton, D.R., Burke, M.C. & Garrett, M.C. Subcutaneous electrocardiogram monitors and their field of view. J. Electrocardiol. 43, 601–605 (2010).
Iglesias, J.F., Graf, D., Pascale, P. & Pruvot, E. The implantable loop recorder: a critical review. Kardiovask. Med. 12, 85–93 (2009).
Manolis, A.S., Linzer, M., Salem, D. & Estes, N.M. Syncope: current diagnostic evaluation and management. Ann. Intern. Med. 112, 850–863 (1990).
Nei, M. et al. EEG and ECG in sudden unexplained death in epilepsy. Epilepsia 45, 338–345 (2004).
Jeong, G.S. et al. Solderable and electroplatable flexible electronic circuit on a porous stretchable elastomer. Nat. Commun. 3, 977 (2012).
Jeong, J.W. et al. Capacitive Epidermal Electronics for Electrically Safe, Long-Term Electrophysiological Measurements. Adv. Healthc. Mater. 3, 642–648 (2014).
Kim, D.-H. et al. Epidermal electronics. Science 333, 838–843 (2011).
Lee, J.H. et al. Shear induced CNT/PDMS conducting thin film for electrode cardiogram (ECG) electrode. BioChip J. 6, 91–98 (2012).
Baek, D.-H. et al. A dry release of polyimide electrodes using Kapton film and application to EEG signal measurements. Microsyst. Technol. 17, 7–14 (2011).
Chou, N., Yoo, S. & Kim, S. A largely deformable surface type neural electrode array based on PDMS. IEEE Trans. Neural Syst. Rehabil. Eng. 21, 544–553 (2013).
Chui, R.W., Derakhchan, K. & Vargas, H.M. Comprehensive analysis of cardiac arrhythmias in telemetered cynomolgus monkeys over a 6 month period. J. Pharmacol. Toxicol. Methods 66, 84–91 (2012).
Cools, F. et al. ECG arrhythmias in non-implanted vs. telemetry-implanted dogs: Need for screening before and sufficient recovery time after implantation. J. Pharmacol. Toxicol. Methods 64, 60–67 (2011).
Moxon, K.A. et al. Nanostructured surface modification of ceramic-based microelectrodes to enhance biocompatibility for a direct brain-machine interface. IEEE Trans. Biomed. Eng. 51, 881–889 (2004).
Vince, V., Thil, M.-A., Veraart, C., Colin, I. & Delbeke, J. Biocompatibility of platinum-metallized silicone rubber: in vivo and in vitro evaluation. J. Biomater. Sci. Polym. Ed. 15, 173–188 (2004).
Hassler, C., Boretius, T. & Stieglitz, T. Polymers for neural implants. J. Polym. Sci. Part B Polym. Phys. 49, 18–33 (2011).
Ordonez, J.S., Boehler, C., Schuettler, M. & Stieglitz, T. Improved polyimide thin-film electrodes for neural implants. in 2012 Annual International Conference of the IEEE EMBS 5134-5137 (IEEE, 2012).
Viventi, J. et al. Flexible, foldable, actively multiplexed, high-density electrode array for mapping brain activity in vivo. Nat. Neurosci. 14, 1599–1605 (2011).
Torres, F., Das Graças, M., Melo, M. & Tosti, A. Management of contact dermatitis due to nickel allergy: an update. Clin. Cosmet. Investig. Dermato. 2, 39 (2009).
Xu, S. et al. Stretchable batteries with self-similar serpentine interconnects and integrated wireless recharging systems. Nat. Commun. 4, 1543 (2013).
Kim, S.H., Moon, J.-H., Kim, J.H., Jeong, S.M. & Lee, S.-H. Flexible, stretchable and implantable PDMS encapsulated cable for implantable medical device. Biomed. Eng. Lett. 1, 199–203 (2011).
Nair, B. Final report on the safety assessment of stearoxy dimethicone, dimethicone, methicone, amino bispropyl dimethicone, aminopropyl dimethicone, amodimethicone, amodimethicone hydroxystearate, behenoxy dimethicone, C24-28 alkyl methicone, C30-45 alkyl methicone, C30-45 alkyl dimethicone, cetearyl methicone, cetyl dimethicone, dimethoxysilyl ethylenediaminopropyl dimethicone, hexyl methicone, hydroxypropyldimethicone, stearamidopropyl dimethicone, stearyl dimethicone, stearyl methicone, and vinyldimethicone. Int. J. Toxicol. 22, 11–35 (2002).
Gao, A.X., Tian, Y.L., Shi, Z.Z. & Yu, L. A Costeffective Microdevice Bridges Microfluidic and Conventional in vitro Scratch/Wound-healing Assay for Personalized Therapy Validation. BioChip J. 10, 56–64 (2016).
Belanger, M.C. & Marois, Y. Hemocompatibility, biocompatibility, inflammatory and in vivo studies of primary reference materials low-density polyethylene and polydimethylsiloxane: a review. J. Biomed. Mater. Res. 58, 467–77 (2001).
Lee, K.K. et al. Polyimide-based intracortical neural implant with improved structural stiffness. J. Micromech. Microeng. 14, 32–37 (2004).
Moon, J.H. et al. Wearable polyimide-PDMS electrodes for intrabody communication. J. Micromech. Microeng. 20 (2010).
Cheung, K.C., Renaud, P., Tanila, H. & Djupsund, K. Flexible polyimide microelectrode array for in vivo recordings and current source density analysis. Biosens. Bioelectron. 22, 1783–1790 (2007).
Webster, J. in Medical instrumentation: application and design (John Wiley & Sons, 2009).
Winter, B.B. & Webster, J.G. Reduction of interference due to common mode voltage in biopotential amplifiers. IEEE Trans. Biomed. Eng. 30, 58–62 (1983).
Lee, S.M. et al. A capacitive, biocompatible and adhesive electrode for long-term and cap-free monitoring of EEG signals. J. Neural. Eng. 10, 036006–036014 (2013).
Delivopoulos, E., Chew, D.J., Minev, I.R., Fawcett, J.W. & Lacour, S.P. Concurrent recordings of bladder afferents from multiple nerves using a microfabricated PDMS microchannel electrode array. Lab Chip 12, 2540–2551 (2012).
Li, T., Huang, Z.Y., Suo, Z., Lacour, S.P. & Wagner, S. Stretchability of thin metal films on elastomer substrates. Appl. Phys. Lett. 85, 3435–3437 (2004).
Lee, S.M., Sim, K.S., Kim, K.K., Lim, Y.G. & Park, K.S. Thin and flexible active electrodes with shield for capacitive electrocardiogram measurement. Med. Bio. Eng. Comput. 48, 447–457 (2010).
Ueno, A. et al. Capacitive sensing of electrocardiographic potential through cloth from the dorsal surface of the body in a supine position: a preliminary study. IEEE Trans. Biomed. Eng. 54, 759–766 (2007).
Fernandes, M., Lee, K., Ram, R., Correia, J. & Mendes, P. Flexible PDMS-based dry electrodes for electro-optic acquisition of ECG signals in wearable devices. in 2010 Annual International Conference of the IEEE Eng Med Biol Soc. 3503-3506 (IEEE, 2010).
Metz, S., Bertsch, A. & Renaud, P. Partial release and detachment of microfabricated metal and polymer structures by anodic metal dissolution. J. Microelectromech. Syst. 14, 383–391 (2005).
Sun, Y. et al. Assessment of the biocompatibility of photosensitive polyimide for implantable medical device use. J. Biomed. Mater. Res. A 90, 648–655 (2009).
Koschwanez, J.H., Carlson, R.H. & Meldrum, D.R. Thin PDMS films using long spin times or tert-butyl alcohol as a solvent. PLoS ONE 4, e4572 (2009).
Author information
Authors and Affiliations
Corresponding authors
Rights and permissions
About this article
Cite this article
Lee, S.M., Byeon, H.J., Kim, B.H. et al. Flexible and implantable capacitive microelectrode for bio-potential acquisition. BioChip J 11, 153–163 (2017). https://doi.org/10.1007/s13206-017-1304-y
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s13206-017-1304-y