Abstract
The acoustic noise and flow condition of tandem propellers in a horizontal axis-type tidal stream power unit, which is composed of counter-rotating propellers and double-rotational armature-type generator without traditional stators, were experimentally investigated. The front and rear propellers rotate in opposite directions and drive the inner and outer armatures, respectively; the rotational torque of the front propeller coincides with the torque of the rear propeller. The front blade profile exerts a great effect on noise generation from the tandem propellers, but the effect of the rear blade profile is comparatively small. The sound pressure level is largely concentrated at low frequencies, and most predominant frequencies can be predicted by Hanson’s method. These predominant frequencies are mainly caused by the tip vortex shedding from the front and rear blades in the counter-rotating propellers. The vortex shedding from the front blade does not affect the rear blade. As a result, the acoustic noise is weakened as long as the diameter of the rear propeller is smaller than the diameter of the front propeller.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
P. L. Fraenkel, Power from marine currents, Journal of Power and Energy, 216 (1) (2002) 1–14.
K. Kubo and T. Kanemoto, Development of intelligent wind turbine unit with tandem wind rotors and double rotational armatures (2nd Report, Characteristics of tandem wind rotors), Journal of Fluid Science and Technology, 3 (3) (2008) 370–378.
Y. Usui, T. Kanemoto and K. Hiraki, Counter-rotating type tidal stream power unit boarded on pillar (Performances and flow conditions of tandem propellers), Journal of Thermal Science, 22 (6) (2013) 580–585.
B. Huang, G. J. Zhu and T. Kanemoto, Design and performance enhancement of a bi-directional counter-rotating type horizontal axis tidal turbine, Ocean Engineering, 128 (2016) 116–123.
B. Huang, Y. Usui, K. Takaki and T. Kanemoto, Optimization of blade setting angles of a counter-rotating type horizontal-axis tidal turbine using response surface methodology and experimental validation, International Journal of Energy Research, 40 (5) (2016) 610–617.
B. Huang and T. Kanemoto, Performance and internal flow of a counter-rotating type tidal stream, Journal of Thermal Science, 24 (5) (2015) 410–416.
B. Huang and T. Kanemoto, Multi-objective numerical optimization of the front blade pitch angle distribution in a counter-rotating type horizontal-axis tidal turbine, Renewable Energy, 81 (2015) 837–844.
K. Kubo, N. Mihara, A. Enishi and T. Kanemoto, Acoustic noise from tandem wind rotors of intelligent wind power unit, Journal of Thermal Science, 19 (2) (2010) 120–125.
F. Odo, A. M. Galal, A. Enishi and T. Kanemoto, Effect of angle of attack and blade tip vortex on the noise level of tandem wind rotors of an intelligent wind power unit, Journal of Environmental Science and Engineering, A 2 (12) (2013) 736–743.
National Institute of Advanced Industrial Science and Technology, http://riodb. ibase. aist. go.jp/db060/(2006).
T. Kanemoto and A. M. Galal, Development of intelligent wind turbine generator with tandem wind rotors and double rotational armatures, JSME International Journal, B 49 (2) (2006) 450–457.
D. B. Hanson, Noise of counter-rotation propellers, Journal of Aircraft, 22 (7) (1985) 609–617.
P. Liu, X. S. Wei, M. W. Heo and T. Kanemoto, Vortices shedding from blade tips of counter-rotating propellers installed in tidal stream power unit, Proc. of 6th Asian Joint Workshop on Thermophysics and Fluid Science, GuiLin, China (2016) 1–5.
Author information
Authors and Affiliations
Corresponding author
Additional information
Recommended by Associate Editor Doo Ho Lee
Pin Liu is currently a postdoctoral researcher at the Institute of Ocean Energy, Saga University, Japan. She received her doctoral degree in engineering in the field of science and advanced technology from Saga University in 2014. Her research interests include axial flow fans, tidal turbines, and relative research in CFD simulation, PIV, and noise analysis.
Rights and permissions
About this article
Cite this article
Liu, P., Odo, F., Murakami, T. et al. Acoustic noise measurement in counter-rotating propellers. J Mech Sci Technol 33, 3187–3192 (2019). https://doi.org/10.1007/s12206-019-0613-6
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12206-019-0613-6