Abstract
Silicon carbide (SiC) thin films were deposited on Si(111) by the hot wire chemical vapour deposition (HWCVD) technique using silane (SiH4) and methane (CH4) gases without hydrogen dilution. The effects of SiH4 to CH4 gas flow ratio (R) on the structural properties, chemical composition and photoluminescence (PL) properties of the films deposited at the different gas flow ratios were investigated and compared. X-ray diffraction (XRD) and Fourier transform infrared (FTIR) spectra revealed a structural transition from amorphous SiC to cubic nano-crystalline SiC films with the increase in the gas flow ratio. Raman scattering confirmed the multi-phased nature of the films. Auger electron spectroscopy showed that the carbon incorporation in the film structure was strongly dependent on the gas flow ratio. A similar broad visible room-temperature PL with two peaks was observed for all SiC films. The main PL emission was correlated to the band to band transition in uniform a-SiC phase and the other lower energy emission was related to the confined a-Si : H clusters in a-SiC matrix. SiC nano-crystallites exhibit no significant contribution to the radiative recombination
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Hamakawa Y, Matsumoto Y, Hirata G and Okamoto H 1989 MRS Proc 164 291
Matsunami H and Kimoto T 1997 Mater. Sci. Eng. R20 125
Rajagopalan T 2003 J. Appl. Phys. 94 5252
Komura Y, Tabata A, Narita T, Kondo A and Mizutani T 2006 J. Non-Cryst. Solids 352 1367
Kerdiles S 2000 Appl. Phys. Lett. 76 2373
Forhan N A E, Fantini M C A and Pereyra I 2004 J. Non-Cryst. Solids 338–340 119
Nainaparampil J J and Zabinski S J 1999 J. Vac. Sci. Technol. A 17 909
Komura Y, Tabata A, Narita T and Kondo A 2008 Thin Solid Films 516 633
Swain B P and Dusane R O 2006 Mater. Chem. Phys. 99 240
Gogoi P, Jha H S and Agarwal P 2010 Thin Solid Films 518 6818
Kaneko T, Hosokawa Y, Suga T and Miyakawa N 2006 Microelectron. Eng. 83 41
Chen T, Köhler F, Heidt A, Huang Y, Finger F and Carius R 2011 Thin Solid Films 519 4511
Miyajima S, Irikawa J, Yamada A and Konagai M 2010 Appl. Phys. Lett. 97 023504
Finger F, Astakhov O, Bronger T, Carius R, Chen T, Dasgupta A, Gordijn A, Houben L, Huang Y, Klein S, Luysberg M, Wang H and Xiao L 2009 Thin Solid Films 517 3507
Klein S, Carius R, Finger F and Houben L 2006 Thin Solid Films 501 169
Tabata A and Komura Y 2007 Surf. Coat. Technol. 201 8986
Zhao Q, Li J C, Zhou H, Wang H, Wang B and Yan H 2004 J. Cryst. Growth 260 176
Mao H -Y, Wuu D -S, Wu B -R, Lo S -Y, Hsieh H -Y and Horng R -H 2012 Thin Solid Films 520 2110
Itoh T, Fujiwara T, Katoh Y, Fukunaga K and Nonomura S 2002 J. Non-Cryst. Solids 880 299–302
Swain B P and Dusane R O 2006 Microelectron. Eng 83 55
Tabata A, Komura Y, Narita T and Kondo A 2009 Thin Solid Films 517 3516
Tabata A and Mori M 2008 Thin Solid Films 516 626
Tabata A, Hoshide Y and Kondo A 2010 Mater. Sci. Eng. B 175 201
Hoshide Y, Komura Y, Tabata A, Kitagawa A and Kondo A 2009 Thin Solid Films 517 3520
Klug H P and Alexander L E 1974 X-ray diffraction procedures or polycrystalline and amorphous materials (New York: Wiley).
Hartel A M, Künle M, Löper P, Janz S and Bett A W 2010 Sol. Energy Mater Sol. Cells 94 1942
Chew Rusli K, Yoon S F, Ahn J, Ligatchev V, Teo E J, Osipowicz T and Watt F 2002 J. Appl. Phys. 92 2937
Ritikos R, Siong C C, Ab Gani S M, Muhamad M R and Rahman S A 2009 Jpn. J. Appl. Phys. 48 101301
Yu W, Wang X, Lu W, Wang S, Bian Y and Fu G 2010 Physica B: Condens. Matter 405 1624
Kaneko T, Nemoto D, Horiguchi A and Miyakawa N 2005 J. Cryst. Growth 275 e1097
Vasin A V, Kolesnik S P, Konchits A A, Rusavsky A V, Lysenko V S, Nazarov A N, Ishikawa Y and Koshka Y 2008 J. Appl. Phys. 103 123710
Smith J E, Brodsky M H, Crowder B L, Nathan M I and Pinczuk A 1971 Phys. Rev. Lett. 26 642
Beeman D, Tsu R and Thorpe M F 1985 Phys. Rev. B 32 874
Wang Y, Yue R and Liu L 2002 Appl. Surf. Sci. 193 138
Cheng Q et al 2008 J. Phys. D: Appl. Phys. 41 055406
Ferrari A C and Robertson J 2000 Phys. Rev. B 61 14095
Ferrari A C and Robertson J 2004 Philos Trans. R. Soc. Lond. A 362 2477
Guruvenket S, Azzi M, Li D, Szpunar J A, Martinu L and Klemberg-Sapieha J E 2010 Surf. Coat. Technol. 204 3358
Rerbal K, Jomard F, Chazalviel J N, Ozanam F and Solomon I 2003 Appl. Phys. Lett 83 45
Dunstan D J and Boulitrop F 1984 Phys. Rev. B 30 5945
Estes M J and Moddel G 1996 Phys. Rev. B 54 14633
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
TEHRANI, F.S. Transformation from amorphous to nano-crystalline SiC thin films prepared by HWCVD technique without hydrogen dilution. Bull Mater Sci 38, 1333–1338 (2015). https://doi.org/10.1007/s12034-015-1018-5
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12034-015-1018-5