The authors have solved scientific and technical problems of mathematical modeling and calculation of thermal efficiency, and also of structural characteristics of packed scrubbers of condensation water cooling of a gas in a film countercurrent regime. By simultaneous solution of the heat-balance equation and the expressions for thermal efficiencies of a packed scrubber in the gas and liquid phases, a relation has been established between the thermal efficiencies of condensation cooling of the gas and heating of the water. With an assigned temperature regime of cooling of the gas and its thermodynamic state, a required gas-phase thermal efficiency is computed. To calculate the actual thermal efficiency of a packed bed, use is made of a cellular model of the flow structure in the liquid and gas phases. An expression has been obtained for calculating the height of the packed bed from the assigned thermal efficiency, structural characteristics of the packing, and flow rates of the gas and water. Agreement with the existing experimental data has been shown and a calculation algorithm has been given. Conclusions on the most efficient packing structures have been drawn.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
I. Z. Aronov, Contact Heating of Water by the Combustion Products of Natural Gas [in Russian], Nauka, Leningrad (1990).
V. A. Uvarov, S. V. Starovedov, A. Yu. Feoktistov, and A. I. Yudin, Procedure of calculating the quantity of heat in escaping gases, Abstracts of Papers, Mezhdunar. Nauch.-Issled. Zh., No. 8 (39), Part 2, 89–91 (2015).
R. N. Khamidullin, Recuperation of the heat of flue gases by contact heat exchangers, Vestn. Tekhnol. Univ., 19, No. 2, 88–90 (2016).
V. I. Karakeyan, V. B. Kol’tsov, and O. V. Kol’tsova, Processes and Apparatuses of Environmental Protection [in Russian], Yurait, Moscow (2018).
O. S. Gorfin, B. F. Zyuzin, and A. V. Mikhailov, Surface-type device for full utilization of the heat of flue gases, Trudy Instorfa, No. 11 (64), 44–48 (2015).
V. A. Kuznetsov, Semiempirical model of convective heat transfer of turbulent gases, J. Eng. Phys. Thermophys., 93, No. 3, 543–550 (2020).
A. G. Laptev and E. A. Lapteva, Determination of the thermal efficiency and height of the blocks of countercurrent cooling tower sprinklers, J. Eng. Phys. Thermophys., 93, No. 3, 693–699 (2020).
V. A. Ponomarenko and Yu. I. Aref’ev, Cooling Towers of Industrial and Power-Engineering Enterprises [in Russian], Énergoatomizdat, Moscow (1998).
V. M. Ramm, Absorption of Gases [in Russian], Khimiya, Moscow (1976).
A. G. Laptev, M. M. Basharov, E. A. Lapteva, and T. M. Farakhov, Models and Efficiency of the Processes of Interphase Transfer. Heat- and Mass-Transfer Processes [in Russian], Tsentr Innovatsionnykh Tekhnologii, Kazan (2020).
A. I. Razinov, A. V. Klinov, and G. S. D’yakonov, Processes and Apparatuses of Chemical Engineering [in Russian], Kazansk. Nats. Issled. Tekhnol. Univ., Kazan (2017).
A. M. Kagan, A. G. Laptev, A. S. Pushnov, and T. M. Farakhov, Contact Packings of Industrial Heat-Exchange Apparatuses [in Russian], Otechestvo, Kazan (2013).
R. F. Vitkovskaya, A. S. Pushnov, and S. Šinkunas, Aerohydrodynamics and Heat and Mass Transfer of Packed Apparatuses [in Russian], Lan’, St. Petersburg (2019).
Author information
Authors and Affiliations
Corresponding author
Additional information
Translated from Inzhenerno-Fizicheskii Zhurnal, Vol. 95, No. 1, pp. 259–266, January–February, 2022.
Rights and permissions
About this article
Cite this article
Laptev, A.G., Lapteva, E.A. Mathematical Model and Thermohydraulic Characteristics of Packed Scrubbers of Condensation Cooling of a Gas. J Eng Phys Thermophy 95, 257–265 (2022). https://doi.org/10.1007/s10891-022-02473-3
Received:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10891-022-02473-3