Abstract
A 2D computational fluid dynamics simulation was carried out using a multiphase flow model with an Eulerian–Eulerian approach for a microalgae culture in an airlift column photobioreactor. Simulation was performed for a \(0.0625\,l/l_{\mathrm{culture}}\cdot \hbox {min}\) inlet airflow. Air, water and microalgae velocity contours showed less gas phase present in the downcomer than in the riser, suggesting the necessity of vigorous mixing in the ascendant portion if homogeneous water and solid flow is to be achieved. Air velocity is smaller in the downcomer (shorter velocity vectors) than in the riser. Water velocity vectors point always in the expected direction, down in the downcomer and up in the riser. Microalgae paths, perhaps due to the small size of the microorganisms, follow the water velocity vectors. As there are fewer hydraulic restrictions to the liquid phase in the riser, a large amount of energy is dissipated by gas–liquid interactions. In the downcomer region, the gas phase is almost nonexistent, and bubble collisions are almost nonexistent as well. A quasi-stagnation zone was found at the lower section of the downcomer, showing that the design requires improvement. Finally, the turbulent kinetic energy is larger at the top and middle region of the riser; meanwhile, it is lower at the downcomer. Similar results were observed for the energy dissipation rate.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
Abbreviations
- \(d_\mathrm{B}\) :
-
Bubble diameter
- \(d_\mathrm{M}\) :
-
Microalgae diameter
- g:
-
Gravity
- \(\mathbf{M}_{\mathrm{I},\alpha }\) :
-
Momentum force at the interphase for \(\alpha \) phase
- \(P_{\alpha }\) :
-
Turbulent kinetic energy production term
- \(\textit{Pr}_{\mathrm{t}}\) :
-
Turbulent Prandtl number
- r :
-
Volume fraction
- t :
-
Time
- u:
-
Phase velocity
- \(\alpha \) :
-
Phase (liquid/gas/solid)
- \(\varepsilon \) :
-
Turbulence energy dissipation rate
- k :
-
Turbulence kinetic energy
- \(\rho \) :
-
Density
- \(\nabla P\) :
-
Pressure gradient
- \(\mu \) :
-
Viscosity
- \(\mu _{\mathrm{g,l}}\) :
-
Bubble-induced liquid viscosity
- \(\mu _{\mathrm{s,l}}\) :
-
Solid-particle-induced liquid viscosity
- \(\mu _{\mathrm{t}}\) :
-
Turbulent viscosity
- \(\Gamma _{\alpha } \) :
-
Dispersion Coefficient
- \(\hbox {l}\) :
-
Liquid phase
- \(\hbox {g}\) :
-
Gas phase
- \(\hbox {s}\) :
-
Solid phase
- \(\hbox {eff}\) :
-
Effective
- I:
-
Interphase force
- D:
-
Draft
- L:
-
Lift
- VM:
-
Virtual mass
- TD:
-
Turbulent dispersion
References
Benavente-Valdés, J., Montañez, J., Aguilar, C., Méndez-Zavala, A., Yaldivia, B.: Tecnología de cultivo de microalgas en fotobiorreactores. Revista Científica de la Universidad Autónoma de Coahuila. 7(4), 1–12 (2012)
Bitog, J., Lee, I., Lee, C., Kim, K., Hwang, H., Hong, S.: Application of computational fluid dynamics for modeling and designing photobioreactors for microalgae production: a review. Comput. Electron. Agric. 76(2), 131–147 (2011)
Pulz, O.: Photobioreactors: production systems for phototrophic microorganisms. Appl. Microbiol. Biotechnol. 57(3), 287–293 (2001)
Xu, L., Rui, L., Feng, W., Chun-Zhao, L.: Development of a draft-tube airlift bioreactor for Botryococcus braunii with an optimized inner structure using computational fluid dynamics. Bioresour. Technol. 199, 300–305 (2012)
Roy, S., Dhotre, M., Joshi, J.: CFD simulation of flow and axial dispersion in external loop airlift reactor. Chem. Eng. Res. Des. 84(8), 677–690 (2006)
Pollard, D., Ison, A., Shamalou, P., Lilly, M.: Reactor heterogeneity with saccharopolyspora erythraea airlift fermentations. Biotechnol. Bioeng. 58(5), 453–463 (1998)
Contreras-Flores, C., Peña-Castro, J., Flores-Cotera, L., Cañizares-Villanueva, R.: Advances in conceptual design of photobioreactors for microalgal culture. Interciencia 28(8), 450–456 (2008)
Razzak, S., Hossaina, M., Rahima, A.: Integrated \(\text{ CO }_{2}\) capture, wastewater treatment and biofuel production by microalgae culturing—a review. Renew. Sustain. Energy Rev. 27, 622–653 (2013)
Hutmacher, D., Singh, H.: Computational fluid dynamics for improved bioreactor design and 3D culture. Trends Biotechnol. 26(4), 166–172 (2008)
Oey, R., Mudde, R., Portela, L., Van Den Akker, H.: Simulation of a slurry airlift using a two-fluid model. Chem. Eng. Sci. 56(2), 673–681 (2001)
García, S., Paternina, E., Pupo, O., Bula, A., Di Mare, L.: CFD simulation of multiphase flow in an airlift column photobioreactor. Glob. NEST J. 16(6), 1121–1134 (2014)
Luo, H., Al-Dahhan, M.: Local characteristics of hydrodynamics in draft tube airlift bioreactor. Chem. Eng. Sci. 63(11), 3057–3068 (2008)
Wang, X., Jia, X., Wen, J.: Transient CFD modeling of toluene waste gas biodegradation in a gas–liquid–solid three-phase airlift loop reactor by immobilized pseudomonas putida. Chem. Eng. J. 172(2–3), 735–745 (2011)
Luo, H., Al-Dahhan, M.: Verification and validation of CFD simulations for local flow dynamics in a draft tube airlift bioreactor. Chem. Eng. Sci. 66(5), 907–923 (2011)
Jones, W., Launder, B.: The prediction of laminarization with a two-equation model of turbulence. Int. J. Heat Mass Transf. 15(2), 301–314 (1972)
Launder, B., Sharma, B.: Application of the energy-dissipation model of turbulence to the calculation of flow near a spinning disc. Lett. Heat Mass Transf. 1(2), 131–137 (1974)
Pfleger, D., Gomes, S., Gilbert, N., Wagner, H.: Hydrodynamic simulations of laboratory scale bubble columns fundamental studies of the Eulerian–Eulerian modelling approach. Chem. Eng. Sci. 54(21), 5091–5099 (1999)
CD-Adapco.: STAR-CCM+ User Guide, Version 8.02. CD-Adapco, New York (2013)
Prochazkova, G., Petr, K., Branyik, T.: Harvesting freshwater chlorella vulgaris with flocculant derived from spent brewer’s yeast. Bioresour. Technol. 177, 28–33 (2015)
Lampert, W., Sommer, U.: Limnoecology: The Ecology of Lakes and Streams. Oxford University Press, New York (1997)
Liu, R., Liu, Y., Liu, C.: Development of an efficient CFD-simulation method to optimize the structure parameters of an airlift sonobioreactor. Chem. Eng. Res. Des. 91, 211–220 (2013)
Acknowledgements
This paper is the result of the research project Implementation of R & D (Microalgae components) to promote development and technology transfer in the agroindustrial production in Departamento del Atlántico, which is funded by Departamento del Atlántico through resources from Sistema General de Regalías–Fondo de Ciencia, Tecnología e Innovación (Grant no. FOESPC 52603 PR0004 Algas).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Calvo, F., Bula, A., Di Mare, L. et al. CFD simulation of multiphase (liquid–solid–gas) flow in an airlift column photobioreactor. Acta Mech 228, 2413–2427 (2017). https://doi.org/10.1007/s00707-017-1828-1
Received:
Revised:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00707-017-1828-1